IVS1-5L1-1Q1-2EO-4LL0-30

Embedded Power for

Business-Critical Continuity

Rev. 7.9.09_145

iVS Series

1 of 11

TM

IntelligentVSPower

Up to 4920 Watts

Total Power: Up to 4920 Watts

Input Voltage:ꢀ85ꢀ-ꢀ264ꢀVdc

ꢀ

120ꢀ-ꢀ300ꢀVdc

# of Outputs: Up to 24

Electrical Specifications

Input

Special Features

•ꢀFullꢀmedicalꢀEN60601ꢀapproval

2

•ꢀIntelligentꢀI C control

Inputꢀrange:

•ꢀVoltageꢀadjustmentꢀonꢀallꢀoutputsꢀ

iVS1ꢀ&ꢀiVS3ꢀ 90ꢀ-ꢀ264ꢀVacꢀ1Ø;ꢀ120ꢀ-ꢀ300ꢀVdcꢀ

iVS6ꢀ&ꢀiVS8 170ꢀ-ꢀ264ꢀVacꢀ3Ø

iVS8H 480ꢀVacꢀnominalꢀ3Ø

2

(manualꢀorꢀI C)

•ꢀConfigurableꢀinputꢀandꢀoutputꢀ

OKꢀsignalsꢀandꢀindicators

380ꢀVacꢀnominalꢀ3Øꢀderateꢀtoꢀ3800ꢀWꢀmax.

•ꢀConfigurableꢀinhibit/enable

•ꢀConfigurableꢀoutputꢀUP/DOWNꢀ

sequencing

Frequency:

47ꢀ-ꢀ440ꢀHz

Inrushꢀcurrent:

Efficiency:

40ꢀAꢀpeakꢀmaximumꢀ(softꢀstart)

Upꢀtoꢀ85%ꢀ@ꢀfullꢀcaseꢀload

•ꢀHighꢀpowerꢀdensityꢀ(12ꢀW/cu-in)

•ꢀIntelligentꢀfanꢀ(speedꢀcontrol/

PowerꢀFactor:

Turn-onꢀtime:

0.99ꢀtyp.ꢀmeetsꢀEN61000-3-2

fault status)

ACꢀonꢀ1.5ꢀsecꢀtypical,ꢀinhibit/enableꢀ150msꢀtypicalꢀProgrammable;ꢀ

50msꢀinternalꢀturn-onꢀdelayꢀ(DualꢀOutputꢀonly)

•ꢀuPꢀcontrolledꢀPFCꢀinputꢀwithꢀ

activeꢀInrushꢀprotection

2

EMIꢀFilter:

CISPRꢀ22/EN55022ꢀLevelꢀ“B”

500ꢀµAꢀmax.ꢀ@ꢀ240ꢀVac;ꢀ47-63ꢀHz

CISPRꢀ22/EN55022ꢀLevelꢀ“B”

•ꢀI Cꢀmonitorꢀofꢀvoltage,ꢀcurrent,ꢀ

and temperature

•ꢀProgrammableꢀvoltage,ꢀcurrentꢀ

Leakageꢀcurrent:

RadiatedꢀEMI:

Holdoverꢀstorage:

2

limit,ꢀinhibit/enableꢀthroughꢀI C

10ꢀmsꢀminimumꢀꢀ(independentꢀofꢀinputꢀVac)ꢀadditionalꢀ20mSECꢀꢀꢀꢀꢀꢀ

holdoverꢀstorageꢀwithꢀoptionalꢀHUPꢀmoduleꢀ

(SEMIꢀF47ꢀcompatible)

•ꢀOptionalꢀextendedꢀhold-upꢀ

module (SEMIꢀF47ꢀcompliance)

•ꢀIncreasedꢀpowerꢀdensityꢀtoꢀ150%

•ꢀOptionalꢀconformalꢀcoating

•ꢀIndustrialꢀtempꢀrangeꢀ(-40ꢀºCꢀtoꢀ

70ꢀºC)

ACꢀOK:

>ꢀ 5msꢀearlyꢀwarningꢀminutesꢀbeforeꢀoutputsꢀloseꢀregulationꢀꢀFullꢀcycleꢀ

rideꢀthruꢀ(50ꢀꢀHz).ꢀꢀProgrammableꢀ

Harmonicꢀdistortion: MeetsꢀEN61000-3-2

•ꢀUsesꢀstandardꢀiMP modules

•ꢀFieldꢀupgradeableꢀfirmware

•ꢀRoHSꢀcompliant

Isolation:

MeetsꢀEN60950ꢀandꢀEN60601

Globalꢀinhibitꢀ/ꢀenable: TTL,ꢀLogicꢀ“1”ꢀandꢀLogicꢀ“0”;ꢀconfigurable

Warranty:

3ꢀyears

Safety

• ULꢀ

ꢀ

UL60950/UL2601

• CSAꢀꢀ

• VDEꢀꢀ

CSA22.2ꢀNo.ꢀ234ꢀLevelꢀ5

EN60950/EN60601-1

• BABTꢀ ComplianceꢀtoꢀENꢀ60950/ꢀ

ꢀꢀ

ꢀ

EN60601ꢀBSꢀ7002

Certificate and report

MarkꢀtoꢀLVD

• CB

• CEꢀ

Embedded Power for

Business-Critical Continuity

Rev. 7.9.09_145

iVS Series

ꢀ of 11

Output

Adjustment range:*

±ꢀ10%ꢀminimumꢀallꢀoutputsꢀ(manual)

2

(fullꢀmoduleꢀadjustmentꢀrangeꢀusingꢀI C)

Factoryꢀsetꢀpointꢀaccuracy:

I Cꢀoutputꢀprogramꢀaccuracy:

1%

± 5%

2

Margining:

Overallꢀregulation:

Ripple:

±ꢀ4ꢀ-ꢀ6%ꢀnominalꢀanalogꢀ(singleꢀoutputꢀmoduleꢀonly)

0.4%ꢀorꢀ20ꢀmVꢀmax.ꢀ(1500ꢀWꢀmodulesꢀ1%ꢀmax.)

RMS:ꢀ0.1%ꢀorꢀ10ꢀmV,ꢀwhicheverꢀisꢀgreater

Pk-Pk:ꢀ1.0%ꢀorꢀ50ꢀmV,ꢀwhicheverꢀisꢀgreater

Bandwidthꢀlimitedꢀtoꢀ20ꢀMHz

Dynamicꢀresponse:

Recoveryꢀtime:

Overcurrent protection:**

<ꢀ2%ꢀorꢀ100ꢀmV,ꢀwithꢀ25%ꢀloadꢀstep

Toꢀwithinꢀ1%ꢀinꢀ<ꢀ300ꢀµsec

2

ConfigurableꢀthroughꢀI Cꢀ(calibrationꢀrequired).ꢀSingleꢀoutputꢀmoduleꢀandꢀ

mainꢀoutputꢀofꢀtheꢀdualꢀoutputꢀmoduleꢀ105-120%ꢀofꢀratedꢀoutputꢀcurrent.ꢀ

Auxꢀoutputꢀofꢀdualꢀoutputꢀmoduleꢀ105-140%ꢀofꢀratedꢀoutputꢀcurrent.ꢀ

SpecialꢀprogrammableꢀOCPꢀdelayꢀonꢀ1500ꢀWꢀmoduleꢀfromꢀ100ꢀmSecꢀtoꢀ

25.5ꢀsecondsꢀwithꢀshutdownꢀfeatures.ꢀ

Short-circuitꢀprotection:

Protectedꢀforꢀcontinuousꢀshort-circuit.ꢀ

Recoveryꢀisꢀautomaticꢀuponꢀremovalꢀofꢀshort

(Shutdownꢀmodeꢀonꢀ1500ꢀWꢀmodule).

2

Overvoltage protection:*

ConfigurableꢀthroughꢀI C

ꢀ

Singleꢀoutputꢀmodule:

Dualꢀoutputꢀmodule:

Tripleꢀoutputꢀmodule:

2ꢀ-ꢀ5.5ꢀVꢀꢀ122ꢀ-ꢀ134%ꢀ;ꢀ6ꢀ-ꢀ60ꢀVꢀꢀ110ꢀ-ꢀ120%

2ꢀ-ꢀ6ꢀVꢀꢀ122ꢀ-ꢀ134%ꢀ;ꢀ8ꢀ-ꢀ28ꢀVꢀꢀ110ꢀ-ꢀ120%

Noꢀovervoltageꢀprotectionꢀprovided

2

Thermal protection:*

ConfigurableꢀthroughꢀI C

Allꢀoutputsꢀdisabledꢀwhenꢀinternalꢀtempꢀexceedsꢀsafeꢀoperatingꢀrange.ꢀ>ꢀ

5msꢀwarningꢀ(ACꢀOKꢀsignal)ꢀbeforeꢀshutdown

Remoteꢀsense:

Uꢀ pꢀtoꢀ0.5ꢀVꢀtotalꢀdropꢀ(notꢀavailableꢀonꢀtripleꢀoutputꢀmodule)

Singleꢀwireꢀparallel:

Currentꢀshareꢀtoꢀwithinꢀ2%ꢀofꢀtotalꢀratedꢀcurrent

2

DCꢀOK:*

+/-5%ꢀofꢀnominal.ꢀCꢀ onfigurableꢀthroughꢀI C

Minimumꢀload:

Notꢀrequired

Housekeepingꢀbiasꢀvoltage:

Module inhibit:*

Output/Outputꢀisolation:

5ꢀVdcꢀ@1.0ꢀAꢀmax.ꢀpresentꢀwheneverꢀACꢀinputꢀisꢀapplied

ConfiguredꢀandꢀcontrolledꢀthroughꢀI C

>ꢀ1ꢀMegohm,ꢀ500ꢀV

2

ꢀ *ꢀ CanꢀbeꢀcontrolledꢀviaꢀI C

2

ꢀ**ꢀ ControlledꢀviaꢀI Cꢀbutꢀrequiresꢀloadꢀcalibrationꢀ(exceptꢀ1500ꢀWꢀmodule)

EnvironmentalꢀSpecifications

Operatingꢀtemperature:

ꢀ-40ꢀ°ꢀtoꢀ70ꢀ°Cꢀambient.ꢀDerateꢀeachꢀoutputꢀ2.5%ꢀperꢀdegreeꢀfromꢀ50ꢀ°ꢀtoꢀ70ꢀ°C.

( -20 °C start up)

Storageꢀtemperature:

ꢀ-40ꢀ°Cꢀtoꢀ85ꢀ°Cꢀ

Electromagneticꢀsusceptibility: DesignedꢀtoꢀmeetꢀEN61000-4;ꢀ-2,ꢀ-3,ꢀ-4,ꢀ-5,ꢀ-6,ꢀ-8,ꢀ-11ꢀLevelꢀ3

Humidity:

Operating;ꢀnon-condensingꢀ10%ꢀtoꢀ95%ꢀRH

Vibration:

IEC68-2-6ꢀtoꢀtheꢀlevelsꢀofꢀIEC721-3-2

MTBFꢀdemonstrated:

>ꢀ550,000ꢀhoursꢀatꢀfullꢀload,ꢀ220ꢀVacꢀꢀandꢀ25ꢀ°Cꢀambientꢀconditions

Embedded Power for

Business-Critical Continuity

Rev. 7.9.09_145

iVS Series

ꢁ of 11

Output Module Line-up

3

5

—

Module Code

1

2

4

Module Type

Single

210ꢀW

35ꢀA

Single

360ꢀW

60ꢀA

Single

750ꢀW

150ꢀA

Single

1500ꢀW

140ꢀA

Dual

144ꢀW

10ꢀA

Triple

36ꢀW

2 A

Maxꢀoutputꢀpower

Maxꢀoutputꢀcurrent

8ꢀ-ꢀ15*,ꢀ24ꢀ-ꢀ28;ꢀ8ꢀ-ꢀ15*,ꢀ8ꢀ-ꢀ15*;ꢀ8ꢀ

6-60ꢀV -ꢀ15*,ꢀ2ꢀ-ꢀ6;ꢀ2ꢀ-ꢀ6,ꢀ2ꢀ-ꢀ6;ꢀ24ꢀ-ꢀ28,ꢀ24ꢀ-ꢀ28;ꢀ

24ꢀ-ꢀ28,ꢀ2ꢀ-ꢀ6

8-15,ꢀ8-15,ꢀ2-6;ꢀ8-15,ꢀ8-15,ꢀ8-15;ꢀ8-

15,ꢀ8-15,ꢀ18-28;ꢀ8-15,ꢀ18-28,ꢀ2-6

Outputꢀvoltagesꢀavailable*

Standardꢀvoltageꢀincrements

2-60ꢀV

25

2-60ꢀV

25

2-60ꢀV

25

18

16

Yes

No

Yes

No

Yes

No

Yes

No

Remoteꢀsense

Yes

No

Yes

Remoteꢀmargin

2

V-Programꢀ-ꢀI C Control

ActiveꢀCurrentꢀShare

ModuleꢀInhibitꢀ-ꢀI C Control

ModuleꢀInhibitꢀ-ꢀAnalog

2

Overvoltage/Overcurrentꢀ

protection

Yes

No

1

Minimum load required

No

1

No

3

No

Slots occupied in any iVS case

2

4

1

*ꢀNote:ꢀContactꢀFactoryꢀforꢀextendedꢀrangeꢀdownꢀtoꢀ6ꢀV

Single

OutputꢀModuleꢀVoltage/Current*

Voltage

2

I C

Voltage

Single Output Module Code

Dual Output***

Triple Output

Code

Adjustment

Ranges****

-

1

2

3

5

4

2ꢀV

2.2ꢀV

3ꢀV

3.3ꢀV

5ꢀV

A

B

C

D

E

35ꢀA 60ꢀA

34ꢀA 58ꢀA

23ꢀA 42 A 97.5ꢀA 140ꢀA 10ꢀA* 10ꢀA*

20 A 36ꢀA 84.4 A 140ꢀA 10ꢀA

18ꢀA 32ꢀA

17ꢀA 31ꢀA

150ꢀA

144ꢀA

136ꢀA

—

10ꢀA

—

2 A

1.8ꢀ-ꢀ2.2

2.0 - 2.4

2.7ꢀ-ꢀ3.3

3.0ꢀ-ꢀ3.6

4.5ꢀ-ꢀ5.5

4.7ꢀ-ꢀ5.7

5.0ꢀ-ꢀ6.1

5.4ꢀ-ꢀ6.6

210ꢀW

750ꢀW

5.2ꢀV

5.5ꢀV

6.0ꢀV

8.0ꢀV

10ꢀV

11ꢀV

12ꢀV

14ꢀV

15ꢀV

18ꢀV

20ꢀV

24ꢀV

28ꢀV

30ꢀV

33ꢀV

36ꢀV

42ꢀV

48ꢀV

54ꢀV

60ꢀV

F

G

H

I

J

K

L

M

N

O

P

Q

R

S

4 A

—

1ꢀA 1ꢀA 1ꢀA

—

7.2ꢀ-ꢀ8.8

75ꢀA

140ꢀA 10ꢀA

9.0ꢀ-ꢀ11.0

9.9ꢀ-ꢀ12.1

10.8ꢀ-ꢀ13.2

12.6ꢀ-ꢀ15.4

13.5ꢀ-ꢀ16.5

16.2ꢀ-ꢀ19.8

18.0ꢀ-ꢀ22.0

21.6ꢀ-ꢀ26.4

25.2ꢀ-ꢀ30.8

27.0ꢀ-ꢀ33.0

29.7ꢀ-ꢀ36.3

32.4ꢀ-ꢀ39.6

37.8ꢀ-ꢀ46.2

43.2ꢀ-ꢀ52.8

48.6ꢀ-ꢀ59.4

54.0ꢀ-ꢀ66.0

68ꢀA 136.3ꢀA 10ꢀA

17ꢀA 30ꢀA 62.5ꢀA

14ꢀA 21ꢀA 53.5ꢀA 107ꢀA 9 A

100ꢀA 8 A

125ꢀA 10ꢀA

14ꢀA 20 A

50ꢀA

11ꢀA 19ꢀA 41.6ꢀA 83.3ꢀA

10.5ꢀA 18ꢀA 37.5ꢀA 75ꢀA

8.5ꢀA 15ꢀA

—

0.5ꢀA 0.5ꢀA

—

360ꢀW

1500ꢀW

—

30ꢀA 62.5ꢀA 4 A

2 A

—

6.7ꢀA 11ꢀA 26.8ꢀA 53.5ꢀA 3ꢀA

Dual

Triple

50ꢀA

6.2ꢀA 10.9ꢀA 22.7ꢀA 35.8ꢀA

5.8ꢀA 10ꢀA 20.8 A

4.2 A 7.5ꢀA 16ꢀA 35.7ꢀA

—

6.5ꢀA 11ꢀA

25ꢀA

T

U

V

W

X

Y

35.8ꢀA

4.0 A 7.5ꢀA 15.6ꢀA 31.2ꢀA

3.7ꢀA 6.0ꢀA 13.9ꢀA 27.7ꢀA

3.5ꢀA 6.0ꢀA 12.5ꢀA 25ꢀA

Contact Factory

Special*

Z

35ꢀA 60ꢀA

20 A 36ꢀA

150ꢀA

80 A

—

140ꢀA

—

10ꢀA

8 A

2.3ꢀ-ꢀ2.6

3.7ꢀ-ꢀ4.4

6.7ꢀ-ꢀ7.1

36ꢀWꢀ

144ꢀW

*ꢀNote:ꢀContactꢀFactoryꢀforꢀextendedꢀrangeꢀdownꢀtoꢀ6ꢀV.

**Incrementsꢀofꢀcurrentꢀnotꢀshownꢀcanꢀbeꢀachievedꢀbyꢀparallelingꢀmodulesꢀ(addꢀcurrentsꢀofꢀeachꢀmoduleꢀselected).

***ꢀTotalꢀoutputꢀpowerꢀonꢀdualꢀmodelꢀmustꢀnotꢀexceedꢀ144ꢀW.

****ꢀForꢀsingleꢀoutputꢀmodulesꢀonly.

Embedded Power for

Business-Critical Continuity

Rev. 7.9.09_145

iVS Series

4 of 11

OrderingꢀInformation

Sampleꢀbelowꢀisꢀ3210ꢀWꢀcaseꢀwithꢀ12ꢀVꢀ@ꢀ125ꢀA;ꢀ24ꢀVꢀ@ꢀ8.5ꢀA;ꢀ5ꢀVꢀ@ꢀ60ꢀA;ꢀ12ꢀVꢀ@ꢀ10ꢀAꢀandꢀ12ꢀVꢀ@ꢀ4ꢀA;ꢀwithꢀnoꢀoptions.

Module/Voltage/Option Codes

First - Module Code

Secondꢀ-ꢀVoltageꢀCode

Thirdꢀꢀ-ꢀOptionꢀCode

Case Size

Case Option Codes

Hardware Code

Software Code

iVS1

- 5L1 - 1Q1- 2EO -4LL0 -

00

-

A

-

###

Case Option Codes

Software code used

forꢀconfigurationꢀ

change.ꢀ“A”ꢀisꢀ

standard

Case Size (mm)

1-Phase Input

Module Codes

Module/voltage/optionꢀcodes

ModuleꢀCodes:

(None)ꢀ=ꢀ36ꢀWꢀtripleꢀO/Pꢀ(1ꢀslot)

1ꢀ=ꢀ210ꢀWꢀsingleꢀO/Pꢀ(1ꢀslot)

2ꢀ=ꢀ360ꢀWꢀsingleꢀO/Pꢀ(2ꢀslot)

3ꢀ=ꢀ750ꢀWꢀsingleꢀO/Pꢀ(3ꢀslot)

5ꢀ=ꢀ1500ꢀWꢀsingleꢀO/Pꢀ(slotꢀ4)

4ꢀ=ꢀ144ꢀWꢀdualꢀO/Pꢀ(1ꢀslot)

HUPꢀ=ꢀExtraꢀ30mSꢀhold-upꢀ(1ꢀslot)

Voltage Codes:

SeeꢀOutputꢀModuleꢀVoltage/Currentꢀꢀꢀ

tableꢀabove

Option Codes:

0ꢀ =ꢀStandard

Factory assembled

forꢀhardwareꢀofꢀ

firmware mods.

FirstꢀDigit

0ꢀ-ꢀ9ꢀ=ꢀParallelꢀcode

(See parallel codes table below)

1ꢀ =ꢀ 5”ꢀxꢀ5”ꢀxꢀ11”;ꢀ1500ꢀWꢀ-ꢀ3210ꢀW,ꢀ9ꢀSlots

ꢀ (127ꢀxꢀ127ꢀxꢀ279.4)

3ꢀ =ꢀ 5”ꢀxꢀ8”ꢀxꢀ11”;ꢀ1800ꢀWꢀ-ꢀ4500ꢀW,ꢀ14ꢀSlots

ꢀ (127ꢀxꢀ203.2ꢀxꢀ279.4)

ꢀ

SecondꢀDigit

3-Phase Input

0ꢀ=ꢀNoꢀoptions

1ꢀ=ꢀReverseꢀair

2ꢀ=ꢀNotꢀused

3ꢀ=ꢀGlobalꢀenable

4ꢀ=ꢀFanꢀOffꢀw/inhibit

5ꢀ=ꢀOptꢀ1ꢀ+ꢀOptꢀ3

6ꢀ=ꢀOptꢀ1ꢀ+ꢀOptꢀ4

7ꢀ=ꢀOptꢀ3ꢀ+ꢀOptꢀ4

8ꢀ=ꢀOptꢀ1ꢀ+ꢀ3ꢀ+ꢀ4

9ꢀ=ꢀFuture

6ꢀ =ꢀ 5”ꢀxꢀ5”ꢀxꢀ11”;ꢀ3120ꢀW,ꢀ9ꢀSlots

ꢀ

ꢀ (127ꢀxꢀ127ꢀxꢀ279.4)

8ꢀ =ꢀ 5”ꢀxꢀ8”ꢀxꢀ11”;ꢀ4920ꢀW,ꢀ14ꢀSlots

ꢀ (127ꢀxꢀ203.2ꢀxꢀ279.4)

8Hꢀ=ꢀ5”ꢀxꢀ8”ꢀxꢀ11”;ꢀ4920ꢀW,ꢀ14ꢀSlots

ꢀ

ꢀ (127ꢀxꢀ203.2ꢀxꢀ279.4)

OrderingꢀNote:

1.ꢀUSBꢀtoꢀI²C module order code

73-769-001

1ꢀ =ꢀModuleꢀenable

2ꢀ =ꢀConstantꢀcurrent

3ꢀ =ꢀ1ꢀ&ꢀ2ꢀcombined

4ꢀ =ꢀSetꢀforꢀuseꢀinꢀstandardꢀ

ꢀ

ꢀ (non-intelligentꢀcase)

5ꢀꢀ=ꢀShutdownꢀmodeꢀforꢀ1500ꢀW

6ꢀ =ꢀ1ꢀ&ꢀ5ꢀcombined

7-9ꢀ Future

Parallel

Code

Slot No.

iVS1, 6

iVS3, 8, 8H

Diagram

Possible Configurations

Diagram

Possible Configurations

210ꢀ210;ꢀ210ꢀ144;ꢀ144ꢀ144

AC 14 13 12 11 10

9

1

AC

5

9

4

8

3

7

2

6

1

2

3

4

1ꢀ&ꢀ2

2ꢀ&ꢀ3

3ꢀ&ꢀ4

4ꢀ&ꢀ5

210ꢀ210;ꢀ210ꢀ144;ꢀ144ꢀ144

8

7

6

5

4

3 2

AC 14 13 12 11 10

9

1

AC

5

9

4

8

3

7

2

6

1

360ꢀ360;ꢀ360ꢀ210;ꢀ360ꢀ144;ꢀ+ꢀabove

8

7

6

5

4

3 2

AC 14 13 12 11 10

9

1

AC

5

9

4

8

3

7

2

6

1

750ꢀ360;ꢀ750ꢀ210;ꢀ750ꢀ144;ꢀ210ꢀ210;ꢀ

210ꢀ144;ꢀ144ꢀ144

750ꢀ750;ꢀ750ꢀ360;ꢀ750ꢀ210;ꢀ750ꢀ144;ꢀ

210ꢀ210;ꢀ210ꢀ144;ꢀ144ꢀ144

8

7

6

5

4

3 2

1500ꢀ210;ꢀ1500ꢀ144;ꢀ210ꢀ210;ꢀ210ꢀ144;ꢀ

144ꢀ144;ꢀ360ꢀ210;ꢀ360ꢀ144

1500ꢀ1500;ꢀ1500ꢀ750;ꢀ1500ꢀ360;ꢀ1500ꢀ210;ꢀ

1500ꢀ144;ꢀ210ꢀ210;ꢀ210ꢀ144;ꢀ144ꢀ144;ꢀ360ꢀ

360;ꢀ360ꢀ210;ꢀ360ꢀ144

AC 14 13 12 11 10

9

1

AC

5

9

4

8

3

7

2

6

1

8

7

6

5

4

3 2

AC 14 13 12 11 10

9

1

AC

5

9

4

8

3

7

2

6

1

5

6

7

3,ꢀ4,ꢀ&ꢀ5

4ꢀ&ꢀ6

750ꢀ210ꢀ210;ꢀ750ꢀ210ꢀ144;ꢀ750ꢀ144ꢀ144

1500ꢀ1500;ꢀ1500ꢀ750

750ꢀ210ꢀ210;ꢀ750ꢀ210ꢀ144;ꢀ750ꢀ144ꢀ144

8

7

6

5

4

3 2

AC

5

9

4

8

3

7

2

6

1

AC 14 13 12 11 10

9

1

AC

5

9

4

8

3

7

2

6

1

4,ꢀ5,ꢀ&ꢀ6

1500ꢀ210ꢀ210;ꢀ1500ꢀ210ꢀ144;ꢀ1500ꢀ144ꢀ

144

1500ꢀ210ꢀ210;ꢀ1500ꢀ210ꢀ144;ꢀ1500ꢀ144ꢀ144

8

7

6

5

4

3 2

AC 14 13 12 11 10

9

1

AC

5

9

4

8

3

7

2

6

1

8

9

A

C

iVS1,6:ꢀ3ꢀ&ꢀ6

iVS3,8,8H:ꢀ4,ꢀ5,ꢀ&ꢀ9

750ꢀ750

1500ꢀ1500;ꢀ1500ꢀ360;ꢀ1500ꢀ144

750ꢀ210ꢀ&ꢀ750ꢀ210

1500ꢀ1500ꢀ1500;ꢀ1500ꢀ1500ꢀ750;ꢀ1500ꢀ1500ꢀ

360;ꢀ1500ꢀ1500ꢀ210;ꢀ1500ꢀ1500ꢀ144

8

7

6

5

4

3 2

AC 14 13 12 11 10

9

1

AC

5

9

4

8

3

7

2

6

1

iVS1,6:ꢀ1ꢀ&ꢀ6

iVS3,ꢀ8,ꢀ8H:ꢀ4,ꢀ5ꢀ&ꢀ9;ꢀ12ꢀ&ꢀ13

1500ꢀ1500ꢀ1500ꢀ360;ꢀ1500ꢀ1500ꢀ1500ꢀ210;ꢀ

1500ꢀ1500ꢀ1500ꢀ144

8

7

6

5

4

3 2

AC

5

9

4

8

3

7

2

6

1

AC 14 13 12 11 10

9

1

iVS1,6:ꢀ3ꢀ&ꢀ4;ꢀ8ꢀ&ꢀ9

iVS3,ꢀ8,ꢀ8H:ꢀ4ꢀ&ꢀ5;ꢀ11ꢀ&ꢀ12

1500ꢀ1500ꢀ&ꢀ750ꢀ750

8

7

6

5

4

3 2

AC 14 13 12 11 10

9

1

AC

5

9

4

8

3

7

2

6

1

iVS1,6:ꢀ3,ꢀ4ꢀ&ꢀ6

iVS3,ꢀ8,ꢀ8H:ꢀ6ꢀ&ꢀ7;ꢀ3,ꢀ4,ꢀ11ꢀ&ꢀ12

750,ꢀ360,ꢀ750

750ꢀ750ꢀ360ꢀ750ꢀ750

8

7

6

5

4

3 2

AC 14 13 12 11 10

9

1

E

F

iVS3,ꢀ8,ꢀ8H:ꢀ3,ꢀ4,ꢀ11,ꢀ&ꢀ12

iVS3,ꢀ8,ꢀ8H:ꢀ3ꢀ&ꢀ4;ꢀ11ꢀ&ꢀ12

iVS3,ꢀ8,ꢀ8H:ꢀ3,4ꢀ&ꢀ9

750ꢀ750ꢀ750ꢀ750

8

7

6

5

4

3 2

AC 14 13 12 11 10

9

1

750ꢀ360ꢀ&ꢀ750ꢀ210;ꢀ750ꢀ750ꢀ&ꢀ750ꢀ750

750ꢀ750ꢀ750

8

7

6

5

4

3 2

AC 14 13 12 11 10

9

1

G

H

8

7

6

5

4

3 2

AC 14 13 12 11 10

9

1

iVS3,ꢀ8,ꢀ8H:ꢀ11ꢀ&ꢀ12

750ꢀ750

8

7

6

5

4

3 2

Embedded Power for

Business-Critical Continuity

Rev. 7.9.09_145

iVS Series

5 of 11

iVSꢀCaseꢀSpecifications

iVS1 and iVS6

ꢀ

Input

S

L

S

L

S

L

S

L

90-264ꢀVacꢀ

1500ꢀWꢀmax.ꢀ 3210ꢀWꢀmax.

170-264ꢀVac

iVS1ꢀ=ꢀ 5”ꢀxꢀ5”ꢀxꢀ11”ꢀ

ꢀ

O

T

9

O

T

8

O

T

6

O

T

7

(ꢀ127ꢀxꢀ127ꢀxꢀ279.4)

9ꢀavailableꢀslots

S

L

O

T

4

S

L

O

T

3

S

L

O

T

2

S

L

O

T

1

S

L

O

T

5

iVS6ꢀ=ꢀ 5”ꢀxꢀ5”ꢀxꢀ11”ꢀ

ꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀN/Aꢀ

ꢀ

170-264ꢀVac

3210ꢀWꢀmax.

ꢀ

(ꢀ127ꢀxꢀ127ꢀxꢀ279.4)ꢀ ꢀ

9ꢀavailableꢀslots

3-phaseꢀonly

iVS3, iVS8, and iVS8H

ꢀ

Input

170-264ꢀVac

S

L

S

L

S

L

S

L

S

L

S

L

90-264ꢀVacꢀ

iVS3 =ꢀ 5”ꢀxꢀ8”ꢀxꢀ11”ꢀ

1800ꢀWꢀmax.ꢀꢀ 4500ꢀWꢀmax.

O

T

O

T

O

T

O

T

O

T

O

T

9

ꢀ

(ꢀ127ꢀxꢀ203.2ꢀxꢀ279.4)

14ꢀavailableꢀslotsꢀ

14

13

12

11

10

S

L

O

T

7

S

L

O

T

6

S

L

O

T

5

S

L

O

T

4

S

L

O

T

3

S

L

O

T

2

S

L

O

T

1

S

L

O

T

8

iVS8ꢀ=ꢀ 5”ꢀxꢀ8”ꢀxꢀ11”ꢀ

ꢀꢀꢀꢀꢀꢀꢀꢀN/Aꢀ

ꢀ

170-264ꢀVac

4920ꢀWꢀmax.

ꢀ

(ꢀ127ꢀxꢀ203.2ꢀxꢀ279.4)ꢀ

14ꢀavailableꢀslots

iVS8Hꢀ=5”ꢀxꢀ8”ꢀxꢀ11”ꢀ

ꢀꢀꢀꢀꢀꢀꢀꢀN/Aꢀ

ꢀ

380ꢀVac

3800ꢀWꢀmax.

480ꢀVac

ꢀ

(ꢀ127ꢀxꢀ203.2ꢀxꢀ279.4)ꢀ

14ꢀavailableꢀslotsꢀ

ꢀ

4920ꢀWꢀmax.

Pin Connectors

AC Input

3 Phase

Single Phase

PFC Input Connector (control & signals)

Figure 1. AC Input

Figure 2. Connector J1

PinꢀNo.

Function

PinꢀꢀNo. Function

L

1

2

3

1

2

3

4

5

6

7

8

9

InputꢀACꢀOKꢀ-ꢀ“emitter”

1

5

N

1

AC neutral

Lineꢀ1

1

2

3

InputꢀACꢀOKꢀ-ꢀ“collector”

GlobalꢀDCꢀOKꢀ-ꢀ“emitter”

~

6

10

2

ACꢀlineꢀ(hot)

Line 2

Chassisꢀ(earth)ꢀ

ground

Matesꢀwithꢀ

4

3

Lineꢀ3

GlobalꢀDCꢀOKꢀ-ꢀ“collector”

Noꢀconnection

Globalꢀinhibit/optionalꢀenableꢀlogicꢀ“0”

Globalꢀinhibit/optionalꢀenableꢀlogicꢀ“1”

Globalꢀinhibit/optionalꢀenableꢀreturn

+5ꢀVSBꢀhousekeeping

Molexꢀ90142-0010ꢀHousing

ꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀ90119-2110ꢀPin

ConnectorꢀKitꢀPartꢀNo.:

ꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀ70-841-004

iVS6

iVS1,ꢀiVS3

Chassisꢀ(earth)

ground

4

L

4

3

2

1

10 +5ꢀVSBꢀhousekeepingꢀreturn

iVS8,ꢀiVS8H

2

I C Bus Output Connector

Figure 3. Connector Jꢀ

PinꢀNo. Function

1

2

Noꢀconnection

3

Noꢀconnection

4

5

6

7

8

9

Serialꢀclockꢀsignalꢀ(SCL)

Serialꢀdataꢀsignalꢀ(SDA)

Address bit 0 (A0)

Addressꢀbitꢀ1ꢀ(A1)

Address bit 2 (A2)

Secondaryꢀreturnꢀ(GND)

Matesꢀwith

Landwinꢀ 2050S1000ꢀhousing

ꢀ

2053T011Pꢀpin

ConnectorꢀKitꢀPartꢀNo.:

ꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀ70-841-023

10

5ꢀVCCꢀexternalꢀbusꢀ(5ꢀVCCꢀbus)

Embedded Power for

Business-Critical Continuity

Rev. 7.9.09_145

iVS Series

ꢂ of 11

iMP Modules

DC-DCꢀConverterꢀOutputꢀModules

ControlꢀSignalꢀInformation,ꢀJ1ꢀControlꢀConnector

Singleꢀ210ꢀWatt

.44” (11.2)

PinꢀNo.ꢀ Function

2X

V+

1ꢀꢀ

2ꢀꢀ

3ꢀꢀ

4ꢀꢀ

5ꢀꢀ

6ꢀꢀ

7ꢀꢀꢀ

8ꢀꢀ

9ꢀꢀ

10ꢀꢀ

ꢀ

+ꢀRemoteꢀSenseꢀ

RemoteꢀMarginꢀ/ꢀV.ꢀProgramꢀ singleꢀo/p

MarginꢀHighꢀ singleꢀo/p

-ꢀRemoteꢀSenseꢀ/ꢀMarginꢀLowꢀ singleꢀorꢀdualꢀo/pꢀmain

Spare

ꢀ

singleꢀorꢀdualꢀo/pꢀmain

ꢀ

M4X8 SCREWS WITH CONICAL WASHER

V-

Module,ꢀIsolatedꢀInhibitꢀ

ModuleꢀInhibitꢀreturnꢀ

CurrentꢀShareꢀ(SWP)ꢀꢀ

+ꢀRemoteꢀSenseꢀV2ꢀ ꢀ

singleꢀorꢀdualꢀo/p

singleꢀorꢀdualꢀo/pꢀmain

dualꢀo/p,ꢀsingleꢀisꢀspare

V ADJ

-ꢀRemoteꢀSenseꢀV2ꢀ

ꢀ

*Note:ꢀAllꢀiMPꢀmodulesꢀhaveꢀaꢀgreenꢀDCOKꢀLED.

ꢀꢀ(exceptꢀforꢀ36ꢀWꢀmodule)

PIN 1

ꢀ

DC OUTPUT CONNECTOR

Figure 4. Connector J1

.32"

(8.1)

1

5

6

10

Matesꢀwith

Molexꢀ90142-0010ꢀHousing

ꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀ90119-2110ꢀPin

Singleꢀ750ꢀWatt

Singleꢀ1500ꢀWatt

Singleꢀ360ꢀWatt

V+

.63"

(16.0)

.59"

(15.0)

.63”

V+

.33”

(8.5)

(16.0)

M 4 X 8 SCREWS WITH

CONICAL WASHER

V-

PIN 1

V ADJ

DC OUTPUT CONNECTOR

V-

.32”

.32"

(8.1)

V-

V+

Dualꢀ144ꢀWatt

Tripleꢀ36ꢀWatt

V1 ADJ

V2 ADJ

V1 +

.46 (11.7)

(4X)

V1 -

V2 +

V1 +

V1 -

V1+

V2+

V1-

V2-

V3-

V2 -

V2 +

V2 -

.30 (7.5)(3X)

V3+

M3X8 SCREWS WITH SPRING WASHER

(4X)

V3 +

V3 -

1.17 (29.7)

.42 (10.7)

V3 ADJ

V2 ADJ

Matesꢀwithꢀ

Molexꢀ09-91-0600ꢀHousingꢀ

ꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀꢀ26-60-5060ꢀPin

V1 ADJ

PIN 1

.32

(8.1)

Embedded Power for

Business-Critical Continuity

Rev. 7.9.09_145

iVS Series

7 of 11

5-InchꢀCaseꢀSize:ꢀiVS1:ꢀ5”ꢀxꢀ5”ꢀxꢀ11”ꢀ(127mmꢀxꢀ127mmꢀxꢀ279.4mm)

Weight:ꢀiVS1ꢀCase:ꢀ6.2ꢀlbs.ꢀ•ꢀ1500ꢀWꢀSingle:ꢀ2.0ꢀlbs.ꢀ•ꢀ750ꢀWꢀSingle:ꢀ1.6ꢀlbs.ꢀ

•ꢀ360ꢀWꢀSingle:ꢀ1.0ꢀlb.•ꢀ210ꢀWꢀSingle:ꢀ0.6ꢀlb.ꢀ•ꢀ144ꢀWꢀDual:ꢀ0.6ꢀlb.

iVSꢀSeries

iVS1ꢀ(1500/3210 WattsꢀMax)

REVERSE AIRFLOW DIRECTION

NORMAL AIRFLOW DIRECTION

127.0 0.ꢀ

B

A

127.0 0.ꢀ

27ꢁ.40 1.27

63.ꢀ

AC INPUT

CONNECTOR

FAN

ꢁ2 X ꢁ2 X 38mm

L

N

PE

127.0 0.ꢁ

101.6 0.ꢁ

USB PROGRAMMING

CONNECTOR OPTION

6ꢀ.ꢀ

SELV CONTROL

CONNECTOR

I²C

C

12.7

11.6

CONNECTOR

AC OK

LED

DC OK

LED

171.ꢀ

OUTPUT MODULE

AREA

1ꢁ.1

M4 MTG HOLES 4 PL

13.ꢀ

33.ꢀ

12.0

ꢀ7.4

“MOUNTING HOLES DIMENSIONS IDENTICAL ON BOTH SIDES”

171.4ꢀ

2ꢁ.0ꢀ

ꢀ.00

12.70

B

114.30

A

171.4ꢀ

1ꢁ.0ꢀ

22.80

Notes

1.ꢀ Input:ꢀꢀBarrierꢀtype.ꢀꢀThreeꢀNo.ꢀ6-32ꢀB.H.ꢀscrewsꢀ(0.375”ꢀcenters).ꢀꢀMaxꢀtorque:ꢀ6ꢀin-lbs.ꢀ(0.67ꢀN-m).

2.ꢀ Controlꢀconnectors:ꢀꢀ(J1)ꢀ10ꢀpositionꢀhousing,ꢀgoldꢀplatedꢀcontacts.ꢀꢀMatesꢀwithꢀMolexꢀ90142-0010ꢀhousingꢀwithꢀ90119-2110ꢀcrimpꢀcontactsꢀ(MolexꢀCꢀ-ꢀGridꢀIIIꢀSeries).

Connectorꢀkitꢀincludesꢀmatingꢀconnectorꢀandꢀ10ꢀpins,ꢀAstecꢀpartꢀ#70-841-004.ꢀ(J2)ꢀ10ꢀpositionꢀhousingꢀ(Landwinꢀ2051P1000T).ꢀMatesꢀwithꢀhousingꢀ2050S1000ꢀ

(Landwin)ꢀwithꢀ2053T011Pꢀ(Landwin)ꢀpins.

3.ꢀ Chassisꢀmaterial:ꢀꢀaluminumꢀwithꢀchemicalꢀfilmꢀcoatingꢀ(conductive).

4.ꢀ Allꢀdimensionsꢀareꢀinꢀmillimetersꢀandꢀinches,ꢀandꢀareꢀtypical.

5.ꢀ Customerꢀmountingꢀ-3ꢀsidesꢀM4,ꢀbottomꢀalsoꢀincludesꢀ8-32ꢀmountingꢀholes.ꢀꢀMax.ꢀpenetrationꢀisꢀ0.155”ꢀ(4.0ꢀmm).ꢀꢀMax.ꢀtorque:ꢀ5ꢀin-lbs.ꢀ(0.57ꢀN-m).

6.ꢀ Outputꢀmoduleꢀconnections:ꢀAllꢀsingleꢀO/PꢀmodulesꢀareꢀM4ꢀxꢀ8mmꢀscrews.ꢀꢀMax.ꢀtorque:ꢀ10ꢀin-lbs.ꢀ(1.13ꢀN-m).

ꢀ

DualꢀO/PꢀmoduleꢀisꢀM3ꢀxꢀ8mmꢀscrews.ꢀꢀMax.ꢀtorque:ꢀ5ꢀin-lbs.ꢀ(0.57ꢀN-m).ꢀ

Embedded Power for

Business-Critical Continuity

Rev. 7.9.09_145

iVS Series

ꢃ of 11

iVSꢀSeries

iVS3ꢀ(1800/4500 WattsꢀMax)

8-InchꢀCaseꢀSize:ꢀiVS3:ꢀ5”ꢀxꢀ8”ꢀxꢀ11”ꢀ(127mmꢀxꢀ203.2mmꢀxꢀ279.4mm)

Weight:ꢀiVS3ꢀCase:ꢀ9.0ꢀlbs.ꢀ•ꢀ1500ꢀWꢀSingleꢀ2.0ꢀlbs.•ꢀ750ꢀWꢀSingle:ꢀ1.6ꢀlbs.ꢀ

•ꢀ360ꢀWꢀSingle:ꢀ1.0ꢀlb.ꢀ•ꢀ210ꢀWꢀSingle:ꢀ0.6ꢀlb.ꢀ•144ꢀWꢀDual:ꢀ0.6ꢀlb.

REVERSE AIRFLOW DIRECTION

B

NORMAL AIRFLOW DIRECTION

203.2 0.5

B

A

ꢀ8

27ꢀ.4 1.27

A

52.6

FAN

AC INPUT

CONNECTOR

80 X 80 X 38mm

USB PROGRAMMING

CONNECTOR OPTION

OUTPUT MODULE

AREA

SELV CONTROL

CONNECTOR

C

I²

C

DC OK LED

42

AC OK LED

171.45

M4 MTG HOLES 4 PL

A

61.2

1ꢀ.1

81.5

“MOUNTING HOLES DIMENSIONS IDENTICAL ON BOTH SIDES

#8-32 MTG HOLES

5PL

MARKED “A”

6, 7 REF

B

2ꢀ.1

171.5

B

A

B

A

B

A

16.2

M4 MTG HOLES

5 PL

A

171.5

1ꢀ.1

MARKED “B”

Notes

1.ꢀ Input:ꢀꢀBarrierꢀtype.ꢀꢀThreeꢀM4ꢀscrewsꢀ(0.512”ꢀcenters).ꢀꢀMaxꢀtorque:ꢀ7ꢀin-lbs.ꢀ(0.79ꢀN-m).

2.ꢀ Controlꢀconnectors:ꢀꢀ(J1)ꢀ10ꢀpositionꢀhousing,ꢀgoldꢀplatedꢀcontacts.ꢀꢀMatesꢀwithꢀMolexꢀ90142-0010ꢀhousingꢀwithꢀ90119-2110ꢀcrimpꢀcontactsꢀ(MolexꢀCꢀ-ꢀGridꢀIIIꢀSeries).

Connectorꢀkitꢀincludesꢀmatingꢀconnectorꢀandꢀ10ꢀpins,ꢀAstecꢀpartꢀ#70-841-004.ꢀ(J2)ꢀ10ꢀpositionꢀhousingꢀ(Landwinꢀ2051P1000T).ꢀMatesꢀwithꢀhousingꢀ2050S1000ꢀ

(Landwin)ꢀwithꢀ2053T011Pꢀ(Landwin)ꢀpins.

3.ꢀ Chassisꢀmaterial:ꢀꢀaluminumꢀwithꢀchemicalꢀfilmꢀcoatingꢀ(conductive).

4.ꢀ Allꢀdimensionsꢀareꢀinꢀmillimetersꢀandꢀinches,ꢀandꢀareꢀtypical.

5.ꢀ Customerꢀmountingꢀ-3ꢀsidesꢀM4,ꢀbottomꢀalsoꢀincludesꢀ8-32ꢀmountingꢀholes.ꢀꢀMax.ꢀpenetrationꢀisꢀ0.155”ꢀ(4.0ꢀmm).ꢀꢀMax.ꢀtorque:ꢀ5ꢀin-lbs.ꢀ(0.57ꢀN-m).ꢀ

6.ꢀ Outputꢀmoduleꢀconnections:ꢀAllꢀsingleꢀO/PꢀmodulesꢀareꢀM4ꢀxꢀ8mmꢀscrews.ꢀꢀMax.ꢀtorque:ꢀ10ꢀin-lbs.ꢀ(1.13ꢀN-m).

ꢀ

DualꢀO/PꢀmoduleꢀisꢀM3ꢀxꢀ8mmꢀscrews.ꢀꢀMax.ꢀtorque:ꢀ5ꢀin-lbs.ꢀ(0.57ꢀN-m).ꢀ

Embedded Power for

Business-Critical Continuity

Rev. 7.9.09_145

iVS Series

9 of 11

iVSꢀSeries

iVS6ꢀ(3210 WattsꢀMax)

5-InchꢀCaseꢀSize:ꢀiVS6:ꢀ5”ꢀxꢀ5”ꢀxꢀ11”ꢀ(127mmꢀxꢀ127mmꢀxꢀ279.4mm)

Weight:ꢀiVS6ꢀCase:ꢀ6.0ꢀlbs.ꢀ•ꢀ1500ꢀWꢀSingleꢀ2.0ꢀlbs.

•ꢀ750ꢀWꢀSingle:ꢀ1.6ꢀlbs.ꢀ•ꢀ360ꢀWꢀSingle:ꢀ1.0ꢀlb.ꢀ

•ꢀ210ꢀWꢀSingle:ꢀ0.6ꢀlb.ꢀ•144ꢀWꢀDual:ꢀ0.6ꢀlb.

279.4±±.ꢀ0

5.ꢀ±ꢀ.50

NORMAL AIRFLOW DIRECTION

REVERSE AIRFLOW DIRECTION

293.ꢀ±±.20

GND000000

2ꢀ.3±ꢀ.60

AC0INPUT

CONNECTOR00000

±27.ꢀ±ꢀ.50

63.5

L±000000

L2000000

L3000000

USB0PROGRAMMING0

CONNECTOR0OPTION0000000

AC0OK

LED00000000

I²C0CONNECTOR00000000

FOR0M40SCREW0(4X)

(FOR0SYSTEM0MOUNT

SELV0CONTROL0

^{CONNECTOR0000}±⁰⁰⁰⁰3.5

±9.±0(2X)

±7±.50(2X)

DC0OK

LED00000000

FOR0M40SCREW0(4X)0

(FOR0SYSTEM0MOUNTING)000000

±7±.50(2X)

±9.±0(2X)

33.5

57.4

±2.ꢀ

±9.±0(2X)

FOR0#8-320SCREW0(4X)

(SYSTEM0MOUNTING)000000

FOR0M40SCREW0(4X)

(FOR0SYSTEM0MOUNTING)000000

±7±.50(2X)

29.±0(2X)

Notes

1.ꢀ Input:ꢀꢀBarrierꢀtype.ꢀꢀFourꢀM3ꢀscrewsꢀ(0.325”ꢀcenters).ꢀꢀMaxꢀtorque:ꢀ6ꢀin-lbs.ꢀ(0.67ꢀN-m).

2.ꢀ Controlꢀconnectors:ꢀꢀ(J1)ꢀ10ꢀpositionꢀhousing,ꢀgoldꢀplatedꢀcontacts.ꢀꢀMatesꢀwithꢀMolexꢀ90142-0010ꢀhousingꢀwithꢀ90119-2110ꢀcrimpꢀcontactsꢀ(MolexꢀCꢀ-ꢀGridꢀIIIꢀSeries).

Connectorꢀkitꢀincludesꢀmatingꢀconnectorꢀandꢀ10ꢀpins,ꢀAstecꢀpartꢀ#70-841-004.ꢀ(J2)ꢀ10ꢀpositionꢀhousingꢀ(Landwinꢀ2051P1000T).ꢀMatesꢀwithꢀhousingꢀ2050S1000ꢀ

(Landwin)ꢀwithꢀ2053T011Pꢀ(Landwin)ꢀpins.

3.ꢀ Chassisꢀmaterial:ꢀꢀaluminumꢀwithꢀchemicalꢀfilmꢀcoatingꢀ(conductive).

4.ꢀ Allꢀdimensionsꢀareꢀinꢀmillimetersꢀandꢀinches,ꢀandꢀareꢀtypical.

5.ꢀ Customerꢀmountingꢀ-3ꢀsidesꢀM4,ꢀbottomꢀalsoꢀincludesꢀ8-32ꢀmountingꢀholes.ꢀꢀMax.ꢀpenetrationꢀisꢀ0.155”ꢀ(4.0ꢀmm).ꢀꢀMax.ꢀtorque:ꢀ5ꢀin-lbs.ꢀ(0.57ꢀN-m).

6.ꢀ Outputꢀmoduleꢀconnections:ꢀAllꢀsingleꢀO/PꢀmodulesꢀareꢀM4ꢀxꢀ8mmꢀscrews.ꢀꢀMax.ꢀtorque:ꢀ10ꢀin-lbs.ꢀ(1.13ꢀN-m).

ꢀ

DualꢀO/PꢀmoduleꢀisꢀM3ꢀxꢀ8mmꢀscrews.ꢀꢀMax.ꢀtorque:ꢀ5ꢀin-lbs.ꢀ(0.57ꢀN-m).ꢀ

Embedded Power for

Business-Critical Continuity

Rev. 7.9.09_145

iVS Series

8-InchꢀCaseꢀSize:ꢀiVS8:ꢀ5”ꢀxꢀ8”ꢀxꢀ11”ꢀ(127mmꢀxꢀ203.2mmꢀxꢀ279.4mm)

iVSꢀSeries

iVS8ꢀ(4920 WattsꢀMax)

Weight:ꢀiVS8ꢀCase:ꢀ9.0ꢀlbs.ꢀ•ꢀ1500ꢀWꢀSingleꢀ2.0ꢀlbs.

•ꢀ750ꢀWꢀSingle:ꢀ1.6ꢀlbs.ꢀ•ꢀ360ꢀWꢀSingle:ꢀ1.0ꢀlb.ꢀ

•ꢀ210ꢀWꢀSingle:ꢀ0.6ꢀlb.ꢀ•144ꢀWꢀDual:ꢀ0.6ꢀꢀlb.

10 of 11

6.8 max

(2x)

NORMAL AIRFLOW DIRECTION

REVERSE AIRFLOW DIRECTION

203.2 0.2

291.1 1.2

279.4 0.2

155.6

52.6

AC Input

Connector

GND

Terminal

USB Programming

Connector Option

19.1 (2x)

171.5 (2x)

MOSYTEM Mounting

for M4 Screw (I3X) (’a’)

171.5 (2x)

I2C Connector

SELV Control

7

31.8

50.7

72.1

Connector

171.5 (2x)

19.1 (3x)

29.1 (3x)

MOSYTEM Mounting for

#8-32 Screw (5X) (’a’)

171.5 (2x)

Notes

1.ꢀ Input:ꢀꢀBarrierꢀtype.ꢀꢀThreeꢀM3.5ꢀscrewsꢀ(0.394”ꢀcenters).ꢀꢀMaxꢀtorque:ꢀ6ꢀin-lbs.ꢀ(0.67ꢀN-m).

2.ꢀ Controlꢀconnectors:ꢀꢀ(J1)ꢀ10ꢀpositionꢀhousing,ꢀgoldꢀplatedꢀcontacts.ꢀꢀMatesꢀwithꢀMolexꢀ90142-0010ꢀhousingꢀwithꢀ90119-2110ꢀcrimpꢀcontactsꢀ(MolexꢀCꢀ-ꢀGridꢀIIIꢀSeries).

Connectorꢀkitꢀincludesꢀmatingꢀconnectorꢀandꢀ10ꢀpins,ꢀAstecꢀpartꢀ#70-841-004.ꢀ(J2)ꢀ10ꢀpositionꢀhousingꢀ(Landwinꢀ2051P1000T).ꢀMatesꢀwithꢀhousingꢀ2050S1000ꢀ

(Landwin)ꢀwithꢀ2053T011Pꢀ(Landwin)ꢀpins.

3.ꢀ Chassisꢀmaterial:ꢀꢀaluminumꢀwithꢀchemicalꢀfilmꢀcoatingꢀ(conductive).

4.ꢀ Allꢀdimensionsꢀareꢀinꢀmillimetersꢀandꢀinches,ꢀandꢀareꢀtypical.

5.ꢀ Customerꢀmountingꢀ-3ꢀsidesꢀM4,ꢀbottomꢀalsoꢀincludesꢀ8-32ꢀmountingꢀholes.ꢀꢀMax.ꢀpenetrationꢀisꢀ0.155”ꢀ(4.0ꢀmm).ꢀꢀMax.ꢀtorque:ꢀ5ꢀin-lbs.ꢀ(0.57ꢀN-m).

6.ꢀ Outputꢀmoduleꢀconnections:ꢀAllꢀsingleꢀO/PꢀmodulesꢀareꢀM4ꢀxꢀ8mmꢀscrews.ꢀꢀMax.ꢀtorque:ꢀ10ꢀin-lbs.ꢀ(1.13ꢀN-m).

ꢀ

DualꢀO/PꢀmoduleꢀisꢀM3ꢀxꢀ8mmꢀscrews.ꢀꢀMax.ꢀtorque:ꢀ5ꢀin-lbs.ꢀ(0.57ꢀN-m).ꢀꢀ

Embedded Power for

Business-Critical Continuity

Rev. 7.9.09_145

iVS Series

OptionalꢀCANBUSꢀorꢀRS485ꢀInterface

Americas

11 of 11

5810ꢀVanꢀAllenꢀWay

Carlsbad,ꢀCAꢀ92008

USA

2

TheꢀRS485/CAN-to-I Cꢀusesꢀ2ꢀInputꢀProtocolsꢀandꢀ1ꢀOutputꢀProtocol.ꢀ

TheꢀInputꢀProtocolsꢀusedꢀareꢀRS485ꢀusingꢀModbusꢀ(CommandꢀIndex:ꢀ0x01),ꢀandꢀCANꢀusingꢀmodifiedꢀ

Modusꢀ(CommandꢀIndex:ꢀ0x02).ꢀ

Telephone:ꢀ+1ꢀ760ꢀ930ꢀ4600

Facsimile:ꢀꢀ +1ꢀ760ꢀ930ꢀ0698

2

Europe (UK)

TheꢀOutputꢀProtocolꢀuseꢀis:ꢀI CꢀwithꢀSMBusꢀsupportꢀ(CommandꢀIndex:ꢀ0x80).

Waterfront Business Park

MerryꢀHill,ꢀDudley

Slave/Server D evice(s)

WestꢀMidlands,ꢀDY5ꢀ1LX

UnitedꢀKingdom

Telephone:ꢀ+44ꢀ(0)ꢀ1384ꢀ842ꢀ211

Facsimile:ꢀ +44ꢀ(0)ꢀ1384ꢀ843ꢀ355

A dapter

Asia (HK)

14/F,ꢀLuꢀPlaza

O utput P rotocols

2ꢀWingꢀYipꢀStreet

KwunꢀTong,ꢀKowloon

HongꢀKong

Telephone:ꢀ+852ꢀ2176ꢀ3333

Facsimile:ꢀ +852ꢀ2176ꢀ3888

I²C w ith SM B us

Support

Forꢀglobalꢀcontact,ꢀvisit:

www.PowerConversion.com

Adapter Protocol

techsupport.embeddedpower

@emerson.com

A dapter C om m and

A dapter C ontrols

Whileꢀeveryꢀprecautionꢀhasꢀbeenꢀtakenꢀtoꢀensureꢀ

accuracyꢀandꢀcompletenessꢀinꢀthisꢀliterature,ꢀEmersonꢀ

NetworkꢀPowerꢀassumesꢀnoꢀresponsibility,ꢀandꢀdisclaimsꢀ

allꢀliabilityꢀforꢀdamagesꢀresultingꢀfromꢀuseꢀofꢀthisꢀ

information or for any errors or omissions.

Input Protocols

R S485 using

M odbus

Emerson Network Power.

Theꢀglobalꢀleaderꢀinꢀenabling

business-critical continuity.

C AN using

M odified M odbus

AC Power

Connectivity

DCꢀPower

M aster/C lient D evice(s)

EmbeddedꢀComputing

Embedded Power

Monitoring

2

RS485/CANꢀ-ꢀtoꢀ-ꢀI C

ForꢀDetailedꢀInfo,ꢀDownloadꢀtheꢀSoftwareꢀRequirementsꢀSpecificationꢀ(SRS)ꢀfromꢀ

www.PowerConversion.com/products/cat/103/iVS-series-ac-dc-power-supplies

Outside Plant

PowerꢀSwitchingꢀ&ꢀControls

PrecisionꢀCooling

Racksꢀ&ꢀIntegratedꢀCabinets

Services

SurgeꢀProtection

EmersonNetworkPower.com

EmersonꢀNetworkꢀPowerꢀandꢀtheꢀEmersonꢀ

NetworkꢀPowerꢀlogoꢀareꢀtrademarksꢀandꢀ

serviceꢀmarksꢀofꢀEmersonꢀElectricꢀCo.ꢀꢀ

iVS CAN RS485

iVS I2C USB


型号：	IVS1-5L1-1Q1-2EO-4LL0-30
厂家：	EMERSON NETWORK POWER
描述：	IVS1-5L1-1Q1-2EO-4LL0-10-A Up to 4920 Watts IVS1-5L1-1Q1-2EO - 4LL0-10 -A高达4920瓦
文件：	总11页 (文件大小：2685K)
中文：	中文翻译
下载：	下载PDF数据表文档文件

IVS1-5L1-1Q1-2EO-4LL0-30 [EMERSON-NETWORKPOWER]

相关型号：

IVS1-5L1-1Q1-2EO-4LL0-31

IVS1-5L1-1Q1-2EO-4LL0-32

IVS1-5L1-1Q1-2EO-4LL0-33

IVS1-5L1-1Q1-2EO-4LL0-34

IVS1-5L1-1Q1-2EO-4LL0-35

IVS1-5L1-1Q1-2EO-4LL0-36

IVS1-5L1-1Q1-2EO-4LL0-37

IVS1-5L1-1Q1-2EO-4LL0-38

IVS1-5L1-1Q1-2EO-4LL0-39

IVS1-5L1-1Q1-2EO-4LL0-40

IVS1-5L1-1Q1-2EO-4LL0-41

IVS1-5L1-1Q1-2EO-4LL0-42