TRC-150S140DT [ETC]
Switch Mode LED Drivers;TRC-150W Dimmable Series
Switch Mode LED Drivers
Constant Current
Aluminum Housing
Electrical Specifications
Input Voltage Range:
100 - 277 Nom. Vac (90 - 305 V Min/Max)
Frequency:
50/60 Hz Nom. (47-63 Hz Min/Max)
>0.90 @ full load, 100V through 277V
Power Factor:
Inrush Current:
Input Current:
65 Amps maximum @ 230 Vac, cold start 25ºC
1.8 A max 100Vac, 0.9 A max 220Vac
Maximum Power:
Line Regulation:
Load Regulation:
Leakage Current:
Typical Efficiency
Turn-on Delay:
Ripple and Noise:
Protection:
150W
± 1%
± 3%
0.75 mA 277 Vac 60Hz
92.5%-93.5% at 220Vac
0.5S typical 110Vac, 0.3S typical 220Vac
13V at 350 mA
Over-Voltage, Over-Temperature (110°C), Lightning,
and Short Circuit Protection with Self Recovery
• Total Power: 150 Watts
• Input Voltage: 100-277 Vac Nom.
• UL Dry & Damp Location Rated
• IP67
Environmental Specifications
Minimum Starting Temp: -35ºC
• Ultra-high Efficiency
• High Power Factor with Active Correction
• UL8750
Storage Temperature:
Humidity:
-40ºC to +85ºC
5% to 100%
Convection
Class A
Cooling:
Sound Rating:
MTBF:
250,000 Hours (350 mA model) @ 110Vac input, 80%
load and 25ºC ambient conditions per MIL-HDBK-217F
230,000 Hours (1400 mA model) @ 110Vac input, 80%
load and 25ºC ambient conditions per MIL-HDBK-217F
Lifetime:
Weight:
350mA: 58,000 Hours @ 220Vac, 80% load, Tc=60ºC
1400mA: 88,000 Hours @ 220Vac, 80% load, Tc=60ºC
3.31 lbs. (1.5 kg)
Dimming - Product Specifications
New Surge Protection and HI-POT Testing
Output Current Output Voltage Max. Output
Typical
Model Number
(mA)*
Range (Vdc)
214~428
166~333
107~214
107~142
53~107
Power (W) Efficiency
TRC-150S035DT
TRC-150S045DT
TRC-150S070DT
TRC-150S105DT
TRC-150S140DT
350
150
150
150
150
150
93.5%
93.0%
93.0%
93.0%
92.5%
450
700
Metal Lock Sheet
Nut
1050
1400
* The output current is adjustable at factory from 50% to 100%.
HI-POT Test
Normal Application
The new design of this LED driver provides 1.4KV surge protection. To properly
HI-POT test this unit, the surge protection must be disconnected. The screw, nut, and
metal lock sheet on the input side of the driver provide for this. To test, first remove
the nut and lock sheet as shown. After testing, secure the nut and lock sheet to
provide line-to-earth protection.
This HI-POT test feature is available on product manufactured after August 15, 2015.
E332160
Note:
LED drivers are designed and intended to operate LED loads only.
Non-LED loading may be outside the specified design limits of our
LED drivers, and therefore cannot be covered by any warranty.
If you desire to use our LED drivers to operate non-LED loads
please contact us to discuss compatibility.
Specifications subject to change without notice.
Rev 9-1-15
Thomas Research Products • 1225 Bowes Rd • Elgin, IL 60123 • T 847-515-3057 • F 847-515-3047 • www.trpssl.com
TRC-150 Dimming Series
SSL Solutions Faster Than The Speed Of Light®
Pg 2 of 3
AC INPUT (3*AWG #18)
Dimming Control Wire
(2*AWG #22)
Black (ACL)
White (ACN)
Green (GND)
Purple (1-10V)
Gray (GND)
DC OUTPUT
(2*AWG #18)
Red (V+)
Blue (V-)
Efficiency / Load
Power Factor / Output Voltage
THD / Output Voltage
95%
1.00
0.95
0.90
0.85
0.80
0.75
0.70
0.65
0.60
20%
16%
12%
8%
90%
85%
80%
120Vac
220Vac
277Vac
120Vac
220Vac
277Vac
75%
120Vac
220Vac
277Vac
4%
70%
60%
0%
70%
80%
90%
100%
60%
70%
80%
90%
100%
60%
70%
80%
90%
100%
Normalized Output Voltage
Normalized Output Voltage
Normalized Output Voltage
Lifetime / Case Temperature (350mA)
Lifetime / Case Temperature (1400mA)
300
250
200
150
100
50
300
250
200
150
100
50
0
40
0
50 Case Temperature (°C)
Case Temperatur7e0(°C)
60
70
80
90
30
40
50
60
80
90
Derating Curve
Derating Curve
100
80
60
40
20
0
100
80
60
40
20
0
100Vac
277Vac
-35
-20
-5
10
25
40
55
70
90
120
150
180
210
240
270
300
330
Ambient Temperature (°C)
Input Voltage (V)
Thomas Research Products • 1225 Bowes Rd • Elgin, IL 60123 • T 847-515-3057 • F 847-515-3047 • www.trpssl.com
TRC-150 Dimming Series
SSL Solutions Faster Than The Speed Of Light®
Pg 3 of 3
Dimming Control (on secondary side)
Parameters
Absolute maximum voltage on the 0~10V input pin
Minimum
-2 V
Typical
—
Maximum
12 V
Source current on 0~10V input pin
0 µA
—
1 mA
The dimmer control is operated from an input signal of 1 – 10 Vdc. Recommended implementations are provided below.
DC Input
Output Current / Dimming Voltage
100%
80%
0-10V Input (Purple)
TRC-150xxxDT
Rin
0-10Vdc
Gnd (Gray)
V
60%
40%
20%
0%
0
2
4
6
8
10
Vdim (V)
Output Current / Rx
External Resistor
TRC-150xxxDT
100%
0-10V Input (Purple)
80%
60%
Rx
Gnd (Gray)
40%
20%
0%
0
20
40
60
80 100 120 140 160 180 200
Rx (kΩ)
Notes:
1. Io is actual output current and Ir is rated current without dimming control.
2. For the driver to operate properly, the load voltage must be maintained above the minimum voltage
threshold (approx. 50% of the max. output voltage for any given model).
3. If the output voltage is maintained above 50% of the maximum output voltage, the dimming control may
be operated over the entire 1-10V range with output current varying from 10% to 100% of Ir.
4. The dimming input signal may be less than 1V; however, no further dimming will occur between 0V and 1V.
5. The internal resistor Rin is 20K, and Vcc is about 15V.
6. Do not connect the GRAY of dimming to the output; otherwise, the LED driver can not work normally.
Safety and EMC Compliance
UL/CUL
UL8750, UL1012, UL935, CSA-C22.2 No. 107.1-01
C E
EN 61347-1, EN61347-2-13
EN 55015
Conducted emission Test & Radiated emission Test
Harmonic current emissions
EN 61000-3-2
EN 61000-3-3
EN 61000-4-2
EN 61000-4-3
EN 61000-4-4
EN 61000-4-5
EN 61000-4-6
EN 61000-4-8
EN 61000-4-11
EN 61547
Voltage fluctuations & flicker
Electrostatic Discharge (ESD): 8 kV air discharge, 4 kV contact discharge
Radio-Frequency Electromagnetic Field Susceptibility Test-RS
Electrical Fast Transient / Burst-EFT
Surge Immunity Test: AC Power Line: line to line 2 kV, line to earth 4 kV
Conducted Radio Frequency Disturbances Test-CS
Power Frequency Magnetic Field Test
Voltage Dips
Electromagnetic Immunity Requirements Applies to Lighting Equipment
Thomas Research Products • 1225 Bowes Rd • Elgin, IL 60123 • T 847-515-3057 • F 847-515-3047 • www.trpssl.com
相关型号:
©2020 ICPDF网 联系我们和版权申明