GAMW3V330SST 概述
48V Input, 3.3VDC, 30A Output 48V输入, 3.3VDC , 30A输出
GAMW3V330SST 数据手册
通过下载GAMW3V330SST数据手册来全面了解它。这个PDF文档包含了所有必要的细节,如产品概述、功能特性、引脚定义、引脚排列图等信息。
PDF下载Mars
48V Input, 3.3VDC, 30A Output
Quarrtteerr--bbrriicckk
The Mars CoolConverter™ is the most
cost-effective 100W quarter-brick on
the market.
Industry Standard Pinout and Footprint
No Heat Sink Required
Very Low Common-mode Noise for a
Commercial DC/DC Converter
Two-stage Input Filter
Constant Switching Frequency
Remote Sense
Single Board Design
Very Low Parts Count
Optional Baseplate or Low Profile Heatsink
for Improved Thermal Performance
Header with M3 Metal Inserts for Mechanical
Connection to PCB
The Mars Series of quarter-
brick DC/DC converters offers
high current performance with
high efficiency at low cost.
Two Year Warranty
Control Functions
GAMW3V330 Features:
48V Input
Uses Patented Power Supply Control
and Architecture
Microprocessor Controlled
Primary-side Enable, Choice of Logic
3.3VDC, 30A Output
High Efficiency:
Protection Features
91% at 3.3V, 30A
91% at 3.3V, 15A
Over Temperature Protection
Over Voltage Protection
Over Current Protection
Over/Under Input Voltage Protection
Typical Characteristics
Output Setpoint Accuracy: ± 1%
Load Regulation: ± 0.2%
Line Regulation: ± 0.2%
Regulation over Line, Load, and
Temperature: ± 2%
Low Output Ripple
Output Trim
ISO 9001 CERTIFIED ORGANISATION
®
Certified to ISO 9001:2000
Part No. 02-GAM-03 Rev. 1.0 – 042805
WWW.GALAXYPWR.COM
GAMW3V330 – 1
Galaxy Power Inc. 155 Flanders Road Westborough, MA 01581 Telephone: 508-870-9775 Fax: 508-870-9796 e-mail: info@galaxypwr.com
General Specifications
V
IN
= 48V , T @25° C, 300 LFM Airflow, V
=3.3V , I
= Full Load unless otherwise noted.
DC
A
OUT
DC OUT
Available output power depends on ambient temperature and good thermal management. (See application graphs for limits.)
Input Characteristics
Parameter
Min
Typ
Max
75
Units
Operating Input Voltage
Input Current (Model Dependent)
Input Capacitance
36
48
V
DC
3.5
A
3
2
µF
Input Hysteresis, Low Line
Output Characteristics
Regulation Over Line, Load & Temperature
Voltage Ripple
V
DC
3.234
3.366
20
V
mV
RMS
P–P
Voltage Ripple, 20MHz BW
Current Range
60
mV
0
30
A
Current Limit Inception
30.9
42
A
A
1
Short Circuit Current, Peak
45
2
Output Transient Response, 50% to 75% load change, 1A/µsec
Settling Time to ± 1%
16
%V
OUT
200
25
µS
Turn-on Time to 98%Vnom
Output Overshoot at Turn-on
Trim Range
mS
0
%V
OUT
OUT
OUT
70
110
%V
%V
Overvoltage Protection, Latching
Isolation
130
Isolation Test Voltage, Input/Output (Basic)
Isolation Resistance
2250
10
V
DC
MΩ
Features
3
Overtemperature Protection, Thermal Sensor, Latching
110
° C
Switching Frequency, Fixed
250
kHz
Notes:
1. During short circuit, converter will shut down and attempt to restart once per second. The average current during this condition will be very low
and the device can be safely left in this condition continuously.
2. Limited by output energy storage. For improved performance see Tuned (T) model information.
3. PCB less than 130° C
General Specifications
Approvals and Standards
Operating Temperature
Storage Temperature
Relative Humidity
–40° C to +100° C
–55° C to +125° C
UL and c-UL Recognized Component, TUV**,
UL60950, CSA 22.2 No. 950, IEC/EN 60950
EMC Characteristics:
10% to 95% RH,
Non-condensing
Designed to meet emission and immunity
requirements per EN55022, CISPR 22, Class B,
and CISPR 24.
Vibration
2 to 9Hz, 3mm disp.,
9 to 200Hz, 1g
** An external fuse shall be used to comply with the requirements.
Material Flammability
UL V-0
35 grams
Telcordia (Bellcore) TBD
Weight
MTBF
GAMW3V330 – 2
WWW.GALAXYPWR.COM
Part No. 02-GAM-03 Rev. 1.0 – 042805
Galaxy Power Inc. 155 Flanders Road Westborough, MA 01581 Telephone: 508-870-9775 Fax: 508-870-9796 e-mail: info@galaxypwr.com
Application Notes
CoolConverter™
Galaxy’s proprietary CoolConverter™ provides:
• Patented single-stage power conversion architecture,
control, and magnetic design allow unprecedented power
density and efficiency in an isolated power supply.
• An advanced microcontroller reduces parts count while
adding features, performance, and flexibility in the design.
• Low common-mode noise as a result of lower capacitance
in the transformer from balanced winding design.
Protection and Control
Valid Input Voltage Range:
The converter measures the input voltage and will
not allow operation outside of the input voltage
specification. As shown by the graphs, hysteresis is
added to both the high and low voltage to prevent
the converter from turning on and off repeatedly
when the voltage is held near either voltage extreme.
At low line this assures the maximum input current is
not exceeded; at high line this assures the semicon-
ductor devices in the converter are not damaged by
excessive voltage stress.
Undervoltage Hysteresis
1.0
0
30
31
32
33
34
35
36
37
Input Voltage (V)
ON/OFF Logic Option:
The ON/OFF control logic can be either Negative
(standard) or Positive to enable the converter. For
Negative logic the ON/OFF pin is brought to below
1.0V with respect to the –INPUT pin to enable the
converter. The pull down must be able to sink
100µA. For Positive logic the ON/OFF pin is brought
to greater than 4.0V with respect to the –INPUT pin
and be limited to less than 10V. To request the
Positive logic version, add the suffix (P) to the stan-
dard part number. The ON/OFF pin has a built-in pull
up resistor of approximately 100kΩ to +5V.
Overvoltage Hysteresis
1.0
0
76.5 77 77.5 78 78.5 79 79.5 80 80
Input Voltage (V)
Part No. 02-GAM-03 Rev. 1.0 – 042805
WWW.GALAXYPWR.COM
GAMW3V330 – 3
Galaxy Power Inc. 155 Flanders Road Westborough, MA 01581 Telephone: 508-870-9775 Fax: 508-870-9796 e-mail: info@galaxypwr.com
Application Notes
Output Over Voltage Protection:
Trim:
The output voltage is constantly monitored by the
microprocessor with a redundant secondary-side
measurement circuit that both shuts down the duty
cycle and triggers the microprocessor to shut down.
If the output voltage exceeds the over-voltage specifi-
cation, the microprocessor will latch the converter off.
To turn the converter on requires either cycling the
ON/OFF pin or power to the converter. This ad-
vanced feature prevents the converter from damaging
the load if there is a converter failure or application
error. If non-latching is required, consult factory.
To trim the output voltage higher, connect the
required trim resistor from the Trim pin to the
+Sense pin. To trim the output voltage lower, con-
nect the required trim resistor from the Trim pin to
the –Sense pin.
Trim-up
3.3 (100+∆%) (100+2∆%)
RTRIM-UP
=
–
5.11kΩ
{
}
1.225∆%
∆%
Thermal Shutdown:
3.3V Trim-up
The printed circuit board temperature is measured
using a semiconductor sensor. If the maximum rated
temperature is exceeded, the converter is latched off.
To re-enable the converter requires cycling the ON/
OFF pin or power to the converter. If non-latching is
required, consult factory.
1000
100
Control Options:
As the behavior of the circuit is determined by
firmware in the microcontroller, specific customer
requirements such as
10
0
2
3
4
5
6
7
8
9
10
1
Increase in Output Voltage (%)
• non-latching thermal protection
• custom valid input voltage range
• controlled delay from initiating an ON/OFF signal
for power sequencing
Trim-down
can be accomplished with no change to hardware.
The standard behavior was chosen based on system
design experience but we understand that customers
often have their own requirements.
100
RTRIM-DOWN
=
– 2 5.11kΩ
{∆% }
Please consult Galaxy Power for your special needs.
Trim-down
Remote Sense:
1000
The output voltage is regulated at the point where
the sense pins connect to the power output pins.
Total sense compensation should not exceed 0.4V or
10% of Vout, whichever is greater.
100
Safety:
An external input fuse must always be used to meet
these safety requirements.
10
0
2
3
4
5
6
7
8
9
10
1
External Output Trimming
Decrease in Output Voltage (%)
+ Sense
Trim
– Sense
GAMW3V330 – 4
WWW.GALAXYPWR.COM
Part No. 02-GAM-03 Rev. 1.0 – 042805
Galaxy Power Inc. 155 Flanders Road Westborough, MA 01581 Telephone: 508-870-9775 Fax: 508-870-9796 e-mail: info@galaxypwr.com
GAMW3V33o Operation
Power Dissipation
Efficiency
14
12
10
8
94
92
90
88
86
84
82
80
6
4
36V Vin
48V Vin
75V Vin
36V Vin
48V Vin
75V Vin
2
0
0
5
10
15
20
25
30
0
5
10
15
20
25
30
Output Current (A)
Output Current (A)
Voltage Ripple
Start Up
CH2
CH3
CH1
1) Vout 20mV/div 2µS/div
10µF ext cap 20MHz BW
1) Vout 1V 4mS/div
2) Iout 10A/div
3) Enable 5V/div
Transient Response
Line/Load Regulation
3.34
3.32
3.30
3.28
3.26
3.24
Setpoint Accuracy 0.3212%
Line Regulation 0.0365%
Load Regulation 0.0182%
Line & Load Regulation 0.0517%
36V Vin
48V Vin
75V Vin
0
5
10
15
20
25
30
Output Current (A)
1) Vout 200mV/div 200µS/div
2) Iout 10A/div
Part No. 02-GAM-03 Rev. 1.0 – 042805
WWW.GALAXYPWR.COM
GAMW3V330 – 5
Galaxy Power Inc. 155 Flanders Road Westborough, MA 01581 Telephone: 508-870-9775 Fax: 508-870-9796 e-mail: info@galaxypwr.com
GAMW3V330 Operation
Back Bias
Over-current Protection
Note: Over-current protection is blip-mode (aka hiccup).
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0
36V Vin
48V Vin
75V Vin
35
37
39
41
43
Output Current (A)
1) Vout 500mV/div 20mS/div
Thermal Derating
Thermal Derating
Lengthwise Airflow
Crosswise Airflow
35
30
25
20
15
10
5
35
30
25
20
15
10
5
300 LFM
200 LFM
100 LFM
300 LFM
200 LFM
100 LFM
0
0
0
10
20
30
40
50
60
70
80
90
0
10
20
30
40
50
60
70
80
90
Ambient Temperature (°C)
Ambient Temperature (°C)
Over Voltage Protection
1) Vout 1V/div 0.25mS/div
GAMW3V330 – 6
WWW.GALAXYPWR.COM
Part No. 02-GAM-03 Rev. 1.0 – 042805
Galaxy Power Inc. 155 Flanders Road Westborough, MA 01581 Telephone: 508-870-9775 Fax: 508-870-9796 e-mail: info@galaxypwr.com
PACKAGE DETAIL
Pin Configuration (Bottom View)
.665 PIN
Pin
1
2
3
4
5
6
7
8
Function
+ Input
On/Off
Pin Dia. (in.)
0.040
0.040
0.040
0.060
0.040
0.040
0.040
0.060
.515 PIN
.365 PIN
.215 PIN
– Input
– Output
– Sense
Trim
Notes:
1. Mechanical tolerances:
x.xxx in. = ± 0.005 in.
x.xx in. = ± 0.01 in.
2. Pin material: brass with tin/lead plating over nickel
3. Workmanship: Meets or exceeds IPC-A-610B Class II
4. "A" = 0.040" dia. pins
+ Sense
+ Output
5. "B" = 0.060" dia. pins
6. Min. screw length for heatsink attachment
= 4.5mm + heatsink flange + locking hardware.
ORDERING INFORMATION
Standard Model
Number
Input
Output
Voltage
Max
Example Part No.:
(All options shown)
Voltage
Current
GAMW3V330*
48V
3.3V
30A
GAMW3V330 PST
* Options:
P
E
= Positive Logic Version; High = On
= 0.18" Pins (± .01")
Part Number
Options:
M = 0.145" Pins (± .01")
S
T
= 0.12" Pins (± .01")
= Tuned model**
Positive Logic Version
Optional Pin Lengths
E = 0.18"
M = 0.145"
S = 0.12"
Tuned Model
**T (Tuned Model) Option
Designed for higher di/dt and ∆I applications, the
transient response has been modified to take advan-
tage of the capacitance on the customer's PCB. This
unit requires a minimum load capacitance of 5600µF
with an impedance magnitude of less than 0.005Ω at
15kHz. It offers a minimum 3X improvement in the
peak response compared to a standard unit.
Galaxy Power Inc. warrants to the original purchaser that the products conform to this data
sheet and are free from material and workmanship defects for a period of two (2) years from
the date of manufacture, if this product is used within specified conditions. Galaxy Power Inc.
reserves the right to make changes to the product(s) or information contained herein without
notice. No liability is assumed as a result of their use or application. No rights under any
patent accompany the sale of any such products or information. For additional details on this
limited warranty consult the factory.
Part No. 02-GAM-03 Rev. 1.0 – 042805
WWW.GALAXYPWR.COM
GAMW3V330 – 7
Galaxy Power Inc. 155 Flanders Road Westborough, MA 01581 Telephone: 508-870-9775 Fax: 508-870-9796 e-mail: info@galaxypwr.com
GAMW3V330SST 相关器件
型号 | 制造商 | 描述 | 价格 | 文档 |
GAMW3V330TET | GALAXY | 48V Input, 3.3VDC, 30A Output | 获取价格 | |
GAMW3V330TMT | GALAXY | 48V Input, 3.3VDC, 30A Output | 获取价格 | |
GAMW3V330TST | GALAXY | 48V Input, 3.3VDC, 30A Output | 获取价格 | |
GAMW5V020 | GALAXY | 48V Input, 5VDC, 20A Output | 获取价格 | |
GAMW5V020EET | GALAXY | 48V Input, 5VDC, 20A Output | 获取价格 | |
GAMW5V020EMT | GALAXY | 48V Input, 5VDC, 20A Output | 获取价格 | |
GAMW5V020EST | GALAXY | 48V Input, 5VDC, 20A Output | 获取价格 | |
GAMW5V020MET | GALAXY | 48V Input, 5VDC, 20A Output | 获取价格 | |
GAMW5V020MMT | GALAXY | 48V Input, 5VDC, 20A Output | 获取价格 | |
GAMW5V020MST | GALAXY | 48V Input, 5VDC, 20A Output | 获取价格 |
GAMW3V330SST 相关文章
- 2024-09-20
- 6
- 2024-09-20
- 9
- 2024-09-20
- 8
- 2024-09-20
- 6