N1863CZ14HOO
更新时间:2024-09-19 02:50:53
品牌:IXYS
描述:Silicon Controlled Rectifier, 7080 A, 1400 V, SCR, 101A325, 3 PIN
N1863CZ14HOO 概述
Silicon Controlled Rectifier, 7080 A, 1400 V, SCR, 101A325, 3 PIN
N1863CZ14HOO 数据手册
通过下载N1863CZ14HOO数据手册来全面了解它。这个PDF文档包含了所有必要的细节,如产品概述、功能特性、引脚定义、引脚排列图等信息。
PDF下载Date : Dec-99
Rat Rep : 99T05
Issue 2
WESTCODE
Converter Thyristor
Type N1863xx12xxx to N1863xx28xxx
Absolute maximum ratings
MAXIMUM
LIMITS
VOLTAGE RATINGS
UNITS
VDRM
VDSM
VRRM
VRSM
Repetitive peak off-state voltage, (note 1).
Non-repetitive peak off-state voltage, (note 1).
Repetitive peak reverse voltage, (note 1).
Non-repetitive peak reverse voltage, (note 1).
1200-2800
1200-2800
1200-2800
1300-2900
V
V
V
V
MAXIMUM
LIMITS
RATINGS
UNITS
IT(AV)
IT(AV)
IT(AV)
IT(RMS)
IT(d.c.)
ITSM
ITSM2
I2t
Mean on-state current, Tsink=55°C, (note 2).
Mean on-state current. Tsink=85°C, (note 5).
Mean on-state current. Tsink=85°C, (note 3).
Nominal RMS on-state current, 25°C, (note 2).
D.C. on-state current, 25°C, (note 7).
3560
A
A
2420
1440
A
7080
A
6040
A
Peak non-repetitive surge tp=10ms, VRM=0.6VRRM, (note 4).
Peak non-repetitive surge tp=10ms, VRM≤10V, (note 4).
I2t capacity for fusing tp=10ms, VRM=0.6VRRM, (note 4).
I2t capacity for fusing tp=10ms, VRM≤10V, (note 4).
I2t capacity for fusing tp=3ms, VRM≤0.6VRRM, (note 4).
Critical rate of rise of on-state current (continuous), (note 6).
Critical rate of rise of on-state current (intermittent), (note 6).
Peak forward gate current.
54.0×103
64.0×103
14.6×106
18.0×106
10.1×106
150
A
A
A2s
A2s
A2s
A/µs
A/µs
A
I2t
I2t
di/dt
300
IFGM
VRGM
PG(AV)
PGM
VGD
10
Peak reverse gate voltage.
5
V
Mean forward gate power.
5
W
Peak forward gate power.
30
W
Non-trigger gate voltage, (Note 5).
0.25
V
THS
Operating temperature range.
-40 to +125
-40 to +150
°C
°C
Tstg
Storage temperature range.
Notes:-
1) De-rating factor of 0.13% per K is applicable for Tj below 25°C.
2) Doubleside cooled, single phase; 50Hz, 180° half-sinewave.
3) Singleside cooled, single phase; 50Hz, 180° half-sinewave.
4) Half-sinewave, 125°C Tj initial.
5) Rated VDRM.
6) VD=67%VDRM, IT=6000A, IFG=2A, tr=500ns.
7) Doubleside cooled.
Types N1863xx12xxx to N1863xx28xxx Rat. Rep. 99T05
page 1 of 8
December, 1999
WESTCODE Positive development in power electronics
N1863xx12xxx to N1863xx28xxx
Characteristics
UNITS
CHARACTERISTICS
MIN
TYP MAX TEST CONDITIONS
IT=6000A.
VTM Maximum peak on-state voltage.
-
-
-
-
-
-
1.5
0.9
0.1
V
V
V0
RT
Threshold voltage.
Slope resistance.
mΩ
Critical rate of rise of off-state
voltage.
VD=80% VDRM
.
dv/dt
200
1000
2000
V/µs
Rated VDRM, (note 2).
Rated VRRM, (note 2).
IDRM Peak off-state current.
IRRM Peak reverse current.
VGT Gate trigger voltage
-
-
-
-
-
-
250
250
3.0
mA
mA
V
Tj=25°C.
Tj=25°C.
IA=3A
VD=10V,
IGT
IH
Gate trigger current
Holding current
-
-
300
mA
-
-
-
1000 Tj=25°C.
mA
K/KW
K/KW
kN
R
-
11
22
77
-
Double side cooled.
Single side cooled.
θ
Thermal resistance junction to
sink.
-
-
-
F
Mounting force.
Weight.
63
-
Wt
1.23
kg
Notes:-
1) Unless otherwise indicated Tj=125°C.
2) Leakage current limit, this will be increased in the future to 300mA
Types N1863xx12xxx to N1863xx28xxx Rating Report 99T05
page 2 of 8
December, 1999
WESTCODE Positive development in power electronics
N1863xx12xxx to N1863xx28xxx
Notes on Ratings and Characteristics
1 Voltage Grade Table
VDSM VDRM VRRM
VRSM
V
VD VR
VDC.
Voltage Grade 'H'
V
12
14
16
18
20
22
24
26
28
1200
1400
1600
1800
2000
2200
2400
2600
2800
1300
1500
1700
1900
2100
2300
2500
2700
2900
780
900
1020
1140
1206
1380
1500
1620
1740
2 Extension of Voltage Grades
This report is applicable to other and higher voltage grades when supply has been agreed by
Sales/Production.
3 De-rating Factor
A blocking voltage de-rating factor of 0.13% per °C is applicable to this device for TJ below 25
°C.
4 Repetitive dv/dt
Higher dv/dt selections are available up to 2000V/µs on request.
5 Computer modelling parameters
5.1 Device dissipation calculations
2
−Vo + Vo + 4 ff 2 rs WAV
IAV
=
2 ff 2 rs
Where Vo = 0.90 V, rs = 0.10mΩ
∆T
∆T = TjMax −THs
WAV
=
Rth
Rth
ff
= Supplementary thermal impedance, see table below.
= Form factor, see table below.
Supplementary Thermal Impedance (at 50Hz operating frequency)
Conduction Angle
6 phase (60°)
0.0118
3 phase (120°)
0.0115
Half wave (180°)
0.0112
d.c.
0.0110
0.0220
Square wave Double Side Cooled
Square wave Single Side Cooled
Sine wave Double Side Cooled
Sine wave Single Side Cooled
0.0236
0.0116
0.0232
0.0230
0.0112
0.0224
0.0224
0.0101
0.0202
Form Factors
Conduction Angle
Square wave
Sine wave
60o
2.45
2.78
120o
1.73
1.88
180o
1.41
1.57
d.c.
1
Types N1863xx12xxx to N1863xx28xxx Rating Report 99T05
page 3 of 8
December, 1999
WESTCODE Positive development in power electronics
N1863xx12xxx to N1863xx28xxx
5.2 Calculating VT using ABCD coefficients
The on-state characteristic IT vs VT, on Fig. 9, is represented in two ways; (i) the well
established V0 and rS tangent and (ii) a set of constants A, B, C, D, forming the coefficients of
the representative equation for VT in terms of IT given below:
VT = A + B.ln(IT ) + C.IT + D. IT
The constants, derived by curve fitting software, are given in this report for both hot and cold
characteristics where possible. The resulting values for VT agree with the true device
characteristic over a current range, which is limited to that plotted.
125°C Coefficients
25°C Coefficients
A
B
C
D
5.54×10-01
A
B
C
D
1.15×1000
1.21×10-01
3.71×10-04
-4.68×10-03
-1.21×10-02
6.41×10-05
1.33×10-03
5.3 D.C. Thermal impedance calculation
−t
p=n
r = r 1− eτ
p
∑
t
p
p=1
Where p = 1 to n, n is the number of terms in the series.
t = Duration of heating pulse in seconds.
r = Thermal resistance at time t.
t
rp = Amplitude of p term.
th
τp = Time Constant of r term.
th
D.C. Double Side Cooled
2
Term
1
3
4
5.214×10-03
9.882×10-01
1.901×10-03
3.481×10-01
2.560×10-03
8.720×10-04
r
p
1.147×10-01
8.180×10-03
τ
p
D.C. Single Side Cooled
Term
1
2
3
4
5
r
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
p
p
τ
Types N1863xx12xxx to N1863xx28xxx Rating Report 99T05
page 4 of 8
December, 1999
WESTCODE Positive development in power electronics
N1863xx12xxx to N1863xx28xxx
Curves
Figure 1, Maximum on-state characteristic
Figure 2, Transient thermal impedance
10000
100
Single side cooled
Double side cooled
10
Tj=125°C
Tj=25°C
1000
1
0.1
N1863CH12-28
99T05-Issue 2
N1863CH12-28
99T05 - Issue 2
100
0.01
0.0001
0
1
2
0.001
0.01
0.1
1
10
100
On state volt drop, VT, (Volts)
Pulse width, tp (seconds).
Figure 3, Maximum non repetitive surge
Figure 4, Gate characteristics, 25°C
1000000
10
Max Peak Vg (rise time of Ig = 1µs)
I2t:VRRM =10V
Pg Max 30W
Pg d.c. 4W
Igt,Vgt
I2t:60%VRRM
100000
10000
1000
Max Vg d.c.
1
ITSM:VRRM=10V
ITSM:60%VRRM
Min Vg d.c.
Igd,Vgd
Tj(initial)=125°C
N1863CH12-28
99T05-Issue 2
N1863CH12-28
99T05-Issue 2
Ga? e MayTemporarily Lose Control
0.1
0.01
1.00E
1
-03
1.00
1
E
0
-02
1
1.00
5
E-01 10
1.00
5
E+
0
00
1.00E+01
0.1
1
10
Duration of
surge (ms)
Duration of surge (Cycles @ 50 Hz)
Gate current, IG, (Amperes).
Types N1863xx12xxx to N1863xx28xxx Rating Report 99T05
page 5 of 8
December, 1999
WESTCODE Positive development in power electronics
N1863xx12xxx to N1863xx28xxx
Figure 5, Power dissipation vs. mean
current, sinewave, double side cooled
Figure 6, Power dissipation vs. mean
current, sinewave, single side cooled
10000
5000
15° 30° 60°
90° 120° 180°
15° 30°
60° 90° 120° 180°
9000
8000
7000
6000
5000
4000
3000
2000
1000
0
4500
4000
3500
3000
2500
2000
1500
1000
500
N1863CH12-28
99T05-Issue 2
N1863CH12-28
99T05-Issue 2
0
0
1000
2000
3000
4000
5000
0
500
1000
1500
2000
2500
3000
Mean on-state current, IT(AV) (A)
Mean on-state current, IT(AV) (A)
Figure 7, Heatsink temperature vs. mean
current, sinewave, double side cooled
Figure 8, Heatsink temperature vs. mean
current, sinewave, single side cooled
140
140
N1863CH12-28
99T05-Issue 2
N1863CH12-28
99T05-Issue 2
120
100
80
120
100
80
60
60
40
40
15° 30°
60° 90° 120° 180°
15° 30°
60°
90° 120° 180°
20
0
20
0
0
1000
2000
3000
4000
5000
0
500
1000
1500
2000
2500
3000
Mean on-state current, IT(AV) (A)
Mean on-state current, IT(AV) (A)
Types N1863xx12xxx to N1863xx28xxx Rating Report 99T05
page 6 of 8
December, 1999
WESTCODE Positive development in power electronics
N1863xx12xxx to N1863xx28xxx
Figure 9, Power dissipation vs. mean
Figure 10, Power dissipation vs. mean
current, squarewave, double side cooled
current, squarewave, single side cooled
10000
5000
30° 60° 90° 120° 180°
DC
30° 60° 90° 120° 180°
DC
9000
8000
7000
6000
5000
4000
3000
2000
1000
0
4500
4000
3500
3000
2500
2000
1500
1000
500
N1863CH12-28
99T05-Issue 2
N1863CH12-28
99T05-Issue 2
0
0
2000
4000
6000
8000
0
1000
2000
3000 4000
Mean on-state current, IT(AV) (A)
Mean on-state current, IT(AV) (A)
Figure 11, Heatsink temperature vs. mean
current, squarewave, double side cooled
Figure 12, Heatsink temperature vs. mean
current, squarewave, single side cooled
140
140
N1863CH12-28
99T05-Issue 2
N1863CH12-28
99T05-Issue 2
120
100
80
120
100
80
60
60
40
40
30° 60° 90° 120° 180°
DC
30° 60° 90° 120° 180°
DC
20
0
20
0
0
2000
4000
6000
8000
0
1000
2000
3000
4000
Mean on-state current, IT(AV) (A)
Mean on-state current, IT(AV) (A)
Types N1863xx12xxx to N1863xx28xxx Rating Report 99T05
page 7 of 8
December, 1999
WESTCODE Positive development in power electronics
N1863xx12xxx to N1863xx28xxx
Outline drawing & ordering information
*
Also available in 36mm height
*
[Standard for VRRM>5.2kV)
ORDERING INFORMATION
(Please quote 12 digit code as below)
N1063
♦
♦
♦ ♦
♦ ♦ ♦
Outline Code
dv/dt Code
H – standard
explosion
Z – enhanced
explosion
Blank =
200V/µs
JOO =
GOO =
300V/µs
KOO =
HOO =
400V/µs
LOO =
Fixed
Type Code
Voltage Code
VDRM / 100
C – 26mm Height
D – 36mm Height
500V/µs
750V/µs
1000V/µs
Typical order code : N1863CZ28 – 2.8kV VDRM, 26mm high, enhanced explosion rating capsule thyristor
U.K: Westcode Semiconductors Ltd
P.O. Box 57, Chippenham, England SN15 1JL
Tel: +44 (0)1249444524 Fax: +44 (0)1249 659448
E-mail: WSL.sales@westcode.com
WESTCODE
USA: Westcode Semiconductors Inc
3270 Cherry Avenue, Long beach, California 90807
Tel: 562 595 6971 Fax: 562 595 8182
http:\\www.westcode.com
In the interest of product improvement, Westcode Semiconductors reserves the right to change specifications at any time without notice
Westcode Semiconductors Ltd
Types N1863xx12xxx to N1863xx28xxx Rating Report 99T05
page 8 of 8
December, 1999
N1863CZ14HOO 相关器件
型号 | 制造商 | 描述 | 价格 | 文档 |
N1863CZ14JOO | IXYS | Silicon Controlled Rectifier, 7080 A, 1400 V, SCR, 101A325, 3 PIN | 获取价格 | |
N1863CZ14KOO | IXYS | Silicon Controlled Rectifier, 7080 A, 1400 V, SCR, 101A325, 3 PIN | 获取价格 | |
N1863CZ16GOO | IXYS | Silicon Controlled Rectifier, 7080A I(T)RMS, 1600V V(DRM), 1600V V(RRM), 1 Element, 101A325, 3 PIN | 获取价格 | |
N1863CZ16HOO | IXYS | Silicon Controlled Rectifier, 7080A I(T)RMS, 1600V V(DRM), 1600V V(RRM), 1 Element, 101A325, 3 PIN | 获取价格 | |
N1863CZ16JOO | IXYS | Silicon Controlled Rectifier, 7080A I(T)RMS, 1600V V(DRM), 1600V V(RRM), 1 Element, 101A325, 3 PIN | 获取价格 | |
N1863CZ16KOO | IXYS | Silicon Controlled Rectifier, 7080A I(T)RMS, 1600V V(DRM), 1600V V(RRM), 1 Element, 101A325, 3 PIN | 获取价格 | |
N1863CZ16LOO | IXYS | Silicon Controlled Rectifier, 7080A I(T)RMS, 1600V V(DRM), 1600V V(RRM), 1 Element, 101A325, 3 PIN | 获取价格 | |
N1863CZ18HOO | IXYS | Silicon Controlled Rectifier, 7080 A, 1800 V, SCR, 101A325, 3 PIN | 获取价格 | |
N1863CZ18KOO | IXYS | Silicon Controlled Rectifier, 7080A I(T)RMS, 1800V V(DRM), 1800V V(RRM), 1 Element, 101A325, 3 PIN | 获取价格 | |
N1863CZ18LOO | IXYS | Silicon Controlled Rectifier, 7080A I(T)RMS, 1800V V(DRM), 1800V V(RRM), 1 Element, 101A325, 3 PIN | 获取价格 |
N1863CZ14HOO 相关文章
- 2024-09-20
- 5
- 2024-09-20
- 8
- 2024-09-20
- 8
- 2024-09-20
- 6