EVL6562A-TM-80W [STMICROELECTRONICS]
80 W high performance transition mode PFC evaluation board; 80瓦的高性能过渡模式PFC评估板型号: | EVL6562A-TM-80W |
厂家: | ST |
描述: | 80 W high performance transition mode PFC evaluation board |
文件: | 总6页 (文件大小:125K) |
中文: | 中文翻译 | 下载: | 下载PDF数据表文档文件 |
EVL6562A-TM-80W
80 W high performance transition mode PFC evaluation board
Data Brief
Features
■ Line voltage range: 88 to 265 V
AC
■ Minimum line frequency (f ): 47 Hz
L
■ Regulated output voltage: 400 V
■ Rated output power: 80 W
■ Maximum 2f output voltage ripple: 10 V pk-pk
L
■ Hold-up time: 20 ms (V
after hold-up time:
DROP
300 V)
■ Minimum switching frequency: 35 kHz
■ Minimum estimated efficiency: 92% (V = 90
IN
V
, P
= 80 W)
OUT
AC
■ Maximum ambient temperature: 50 °C
■ PCB type and size: single side, 35 µm, CEM-1,
108 x 57 mm
Description
The L6562A is a current-mode PFC controller
operating in transition mode (TM). With the same
pin-out as its predecessor L6562, the L6562A
offers improved performance mainly in terms of
efficiency and noise immunity.
This board implements an 80 W, wide-range
mains input and a PFC pre-conditioner suitable
for ballast, adapters, flat screen displays, etc.
October 2007
Rev 2
1/6
For further information contact your local STMicroelectronics sales office.
www.st.com
6
Electrical specification and performance
EVL6562A-TM-80W
1
Electrical specification and performance
Figure 1.
EVL6562A-TM-80W schematic
Vo=400V
D1
STTH1L06
NTC
2.5 Ω
Po=80W
T1
R4
R5
D8
C5
R14
R11
Ω
Ω
270 k 270 k
1N4148
10 nF
100Ω
Ω
1M
R50 - 22 kΩ
C3 - 2200 nF
D2
1N5248B
R1
1 MΩ
R12
1M
Ω
R6
47 kΩ
C1
0.22 µF
630V
P1
W08
C23
150 nF
ZCD COMP
INV
+
-
F1
4A/250V
C6
47 µF
450V
R2
1 MΩ
VCC
8
3
5
2
1
R7
33 Ω
Q1
STP8NM50FP
MULT
GD
7
Vac
88V
to
L6562A
6
4
R8
47kΩ
R15
264V
CS
GND
C2
10nF
C29
22 µF
25V
SHORTED
R3
15 kΩ
C4
100 nF
R9
0.68 Ω
0.25W
R10
0.68 Ω
0.25W
R13
15 kΩ
R13B
82 kΩ
Boost Inductor Spec (ITACOIL E2543/E)
E25x13x7 core, N67 ferrite
1.5 mm gap for 0.7 mH primary inductance
Primary: 102 turns 20x0.1 mm
Secondary: 10 turns 0.1 mm
Table 1.
Des.
Bill of material
Part type / part
value
Description
Supplier
F1
Fuse 4 A
W06
Fuse T4A - time delay
Wichmann
P1
C1
C2
C3
C4
C5
C6
C23
C29
R1
R2
R3
R4
R5
R6
R7
600 V-1 A Single phase bridge rectifier
B32653-A6224-K - film capacitor
50 V cercap - general purpose
Chenyi electronics
Epcos
220 NF-630 V
10 NF
Avx
2u2F
SR305E225MAR - 50 V ceramic capacitor - Z5U
50 V cercap - general purpose
Avx
100NF
10NF
Avx
50 V cercap - general purpose
Avx
47 µF-450 V
150NF
22 µF-50 V
1M0
aluminium elcap - ED series - 85°C
Daewoo
50 V cercap - general purpose
Avx
aluminium elcap - YK - 85°C
Rubycon
BC Components
BC Components
BC Components
MBB0207 axial film res - 0.4 W - 1% - 50 ppm/°C
MBB0207 axial film res - 0.4 W - 1% - 50 ppm/°C
MBB0207 axial film res - 0.4 W - 1% - 50 ppm/°C
1M0
15 K
270 K
SFR25 axial stand. film res - 0.4 W - 5% - 250 ppm/°C BC Components
SFR25 axial stand. film res - 0.4 W - 5% - 250 ppm/°C BC Components
SFR25 axial stand. film res - 0.4 W - 5% - 250 ppm/°C BC Components
SFR25 axial stand. film res - 0.4 W - 5% - 250 ppm/°C BC Components
270 K
47 K
33R
2/6
EVL6562A-TM-80W
Electrical specification and performance
Supplier
Table 1.
Des.
Bill of material (continued)
Part type / part
value
Description
R8
47 K
SFR25 axial stand. film res - 0.4 W - 5% - 250 ppm/°C BC Components
SFR25 axial stand. film res - 0.4 W - 5% - 250 ppm/°C BC Components
SFR25 axial stand. film res - 0.4 W - 5% - 250 ppm/°C BC Components
R9
0R68
R10
R11
R12
R13
R13B
R14
R15
R50
D1
0R68
1M0
MBB0207 axial film res - 0.4 W - 1% - 50 ppm/°C
MBB0207 axial film res - 0.4 W - 1% - 50 ppm/°C
MBB0207 axial film res - 0.4 W - 1% - 50 ppm/°C
MBB0207 axial film res - 0.4 W - 1% - 50 ppm/°C
BC Components
BC Components
BC Components
BC Components
1M0
15 K
82 K
100 R
SFR25 axial stand. film res - 0.4 W - 5% - 250 ppm/°C BC Components
Tinner wire jumper
Shorted
22 K
SFR25 axial stand. film res - 0.4 W - 5% - 250 ppm/°C BC Components
STTH1L06
1N5248B
IN4148
2R5-S237
E2543/E
L6562A
STP8NM50FP
FK218 32
MKDS 1,5/
MKDS 1,5/
Fuse 4 A
W06
Ultrafast high voltage rectifier
18V-0.5W zener diode
STMicroelectronics
Fairchild
D2
D8
fast switching diodE
Vishay
NTC1
T1
B57237S0259M000
Epcos
E25x13x7 core, 0.7 mH
Itacoil
U1
Transition mode PFC controller
n-channel md-mesh Power MOSFET
Q1 heat sink for TO-220 - 21 °C/W
PCB term. block, screw conn., pitch 5 mm - 3 W.
PCB Term. block, screw conn., pitch 5 mm - 3 W.
Fuse T4A - time delay
STMicroelectronics
STMicroelectronics
Fischer elektronik
Phoenix contact
Phoenix contact
Wichmann
Q1
HS1
J1
J2
F1
P1
600 V-1 A single phase bridge rectifier
Chenyi electronics
3/6
Electrical specification and performance
EVL6562A-TM-80W
Figure 2.
EVL6562A-TM-80W: efficiency vs
Vin
Figure 3.
EVL6562A-TM-80W: static Vout
regulation vs Vin
404
403.5
403
100
95
Pout = 80W
402.5
402
90
Pout = 80W
85
401.5
401
80
400.5
75
80
400
80
100
120
140
160
180
200
220
240
260
100
120
140
160
180
200
220
240
260
Vin (Vac)
Vin (Vac)
Figure 4.
EVL6562A-TM-80W: PF vs Vin
Figure 5.
EVL6562A-TM-80W: THD vs Vin
1.00
12
10
0.95
0.90
0.85
0.80
8
6
4
2
0
Pout = 80W
Pout = 80W
80
100
120
140
160
180
200
220
240
260
80
100
120
140
160
180
200
220
240
260
Vin (Vac)
Vin (Vac)
4/6
EVL6562A-TM-80W
Revision history
2
Revision history
Table 2.
Date
Document revision history
Revision
Changes
07-Aug-2007
11-Oct-2007
1
2
Initial release
Document reformatted no content change
5/6
EVL6562A-TM-80W
Please Read Carefully:
Information in this document is provided solely in connection with ST products. STMicroelectronics NV and its subsidiaries (“ST”) reserve the
right to make changes, corrections, modifications or improvements, to this document, and the products and services described herein at any
time, without notice.
All ST products are sold pursuant to ST’s terms and conditions of sale.
Purchasers are solely responsible for the choice, selection and use of the ST products and services described herein, and ST assumes no
liability whatsoever relating to the choice, selection or use of the ST products and services described herein.
No license, express or implied, by estoppel or otherwise, to any intellectual property rights is granted under this document. If any part of this
document refers to any third party products or services it shall not be deemed a license grant by ST for the use of such third party products
or services, or any intellectual property contained therein or considered as a warranty covering the use in any manner whatsoever of such
third party products or services or any intellectual property contained therein.
UNLESS OTHERWISE SET FORTH IN ST’S TERMS AND CONDITIONS OF SALE ST DISCLAIMS ANY EXPRESS OR IMPLIED
WARRANTY WITH RESPECT TO THE USE AND/OR SALE OF ST PRODUCTS INCLUDING WITHOUT LIMITATION IMPLIED
WARRANTIES OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE (AND THEIR EQUIVALENTS UNDER THE LAWS
OF ANY JURISDICTION), OR INFRINGEMENT OF ANY PATENT, COPYRIGHT OR OTHER INTELLECTUAL PROPERTY RIGHT.
UNLESS EXPRESSLY APPROVED IN WRITING BY AN AUTHORIZED ST REPRESENTATIVE, ST PRODUCTS ARE NOT
RECOMMENDED, AUTHORIZED OR WARRANTED FOR USE IN MILITARY, AIR CRAFT, SPACE, LIFE SAVING, OR LIFE SUSTAINING
APPLICATIONS, NOR IN PRODUCTS OR SYSTEMS WHERE FAILURE OR MALFUNCTION MAY RESULT IN PERSONAL INJURY,
DEATH, OR SEVERE PROPERTY OR ENVIRONMENTAL DAMAGE. ST PRODUCTS WHICH ARE NOT SPECIFIED AS "AUTOMOTIVE
GRADE" MAY ONLY BE USED IN AUTOMOTIVE APPLICATIONS AT USER’S OWN RISK.
Resale of ST products with provisions different from the statements and/or technical features set forth in this document shall immediately void
any warranty granted by ST for the ST product or service described herein and shall not create or extend in any manner whatsoever, any
liability of ST.
ST and the ST logo are trademarks or registered trademarks of ST in various countries.
Information in this document supersedes and replaces all information previously supplied.
The ST logo is a registered trademark of STMicroelectronics. All other names are the property of their respective owners.
© 2007 STMicroelectronics - All rights reserved
STMicroelectronics group of companies
Australia - Belgium - Brazil - Canada - China - Czech Republic - Finland - France - Germany - Hong Kong - India - Israel - Italy - Japan -
Malaysia - Malta - Morocco - Singapore - Spain - Sweden - Switzerland - United Kingdom - United States of America
www.st.com
6/6
相关型号:
EVL6564-50WFLB
50 W wide-range high power factor flyback converter demonstration board based on the L6564
STMICROELECTR
EVL6564H-100W
100 W transition-mode PFC pre-regulator demonstration board based on the L6564H
STMICROELECTR
EVL6566A-75WADP
19 V - 75 W laptop adapter with tracking boost PFC pre-regulator, using the L6563 and the L6566A
STMICROELECTR
EVL6699-90WADP
19 V - 90 W adapter with PFC for laptop computers based on the L6563H and L6699
STMICROELECTR
©2020 ICPDF网 联系我们和版权申明