TS2596CM505 [TSC]
3A Step Down Switching Voltage Regulator; 3A降压开关稳压器型号: | TS2596CM505 |
厂家: | TAIWAN SEMICONDUCTOR COMPANY, LTD |
描述: | 3A Step Down Switching Voltage Regulator |
文件: | 总6页 (文件大小:132K) |
中文: | 中文翻译 | 下载: | 下载PDF数据表文档文件 |
TS2596
Preliminary
3A Step Down Switching Voltage Regulator
Pin assignment:
1. Input
150KHz Oscillating Frequency
2. Output
Output Current up to 3A
3. Ground
Enable Input Control
4. Feedback
5. Enable
General Description
The TS2596 Series are step-down switching regulators with all required active functions. It is capable of driving 3A load
with excellent line and load regulations. These devices are available in fixed output voltages of 3.3V, 5V, and an
adjustable output version.
The TS2596 series operates at a switching frequency of 150kHz thus allowing smaller sized filter components than what
would be needed with lower frequency switching regulators. It substantially not only reduces the area of board size but
also the size of heat sink, and in some cases no heat sink is required. The ±4% tolerance on output voltage within
specified input voltages and output load conditions is guaranteed. Also, the oscillator frequency accuracy is within ±10%.
External shutdown is included. Featuring 70µA (typical) standby current. The output switch includes cycle-by-cycle current
limiting, as well as thermal shutdown for full protection under fault conditions.
This series are offered in 5-pin TO-263, TO-220 package.
Features
Ordering Information
Guaranteed 3A output current
Operating Temp.
Part No.
Package
TO-220-5L
TO-263-5L
3.3V, 5V, and adjustable versions
(Ambient)
Wide input voltage range, up to 40V
TS2596CZ5xx
TS2596CZ5
Internal oscillator of 150KHz fixed frequency
Wide adjust version output voltage range, from 1.23V
to 25V ±4% max. at over line and load conditions.
Low standby current, typ. 70µA, at shutdown mode
Requires only 4 external components
-20 ~ +85 oC
TS2596CM5xx
TS2596CM5
Note: Where xx denotes voltage option, available are
5V and 3.3V. Leave blank for adjustable
version. Contact factory for additional voltage
options.
Thermal shutdown and current limit protection
P+ product enhancement tested
Applications
LCD Monitors
ADD-ON Cards Switching Regulators
High Efficiency Step-Down Regulators
Efficient Pre-regulator for Linear Regulator
Absolute Maximum Rating
Input Voltage
Vin
+40
-0.3V ≤ V ≤ Vin
Internal Limited
-40 ~ +125
-65 ~ +150
5
V
V
ENABLE Pin Input Voltage
Power Dissipation
Vin (operate)
PD
TJ
W
oC
oC
S
Operating Junction Temperature Range
Storage Temperature Range
Lead Soldering Temperature (260 oC)
TSTG
TS2596
1-6
2003/12 rev. D
Thermal Performance
Condition
Symbol
Θja
Limits
Unit
oC/W
Thermal Resistance Junction to Ambient
Thermal Resistance Junction to Case
30
3
Θjc
Recommended Operating Conditions (Ta = 25 oC)
Condition
Symbol
Vin
Limits
4.5 ~ 28
0 ~ +20
Unit
V
Input Voltage
ENABLE Pin Input Voltage
Vin (operate)
V
Block Diagram
Electrical Characteristics
Vin = 12V, IL = 500mA, Ta = 25 oC unless otherwise specified.
Parameter
TS2596-3.3V
Conditions
Min
Typ
Max
Unit
0.2A ≤ IL ≤ 3A, 5.07V ≤ Vin ≤ 40V
(Figure 1)
Output Voltage (Note 1)
0.96|Vo|
--
3.3
75
1.04|Vo|
--
V
Efficiency
Vin=12V, IL=3A
%
TS2596-5V
0.2A ≤ IL ≤ 3A, 8V ≤ Vin ≤ 40V
(Figure 1)
Output Voltage (Note 1)
Efficiency
0.96|Vo|
--
5.0
80
1.04|Vo|
--
V
Vin=12V, IL=3A
%
TS2596
2-6
2003/12 rev. D
Electrical Characteristics (Continued)
Vin = 12V, IL = 500mA, Ta = 25 oC unless otherwise specified.
TS2596 Adjustable
0.2A ≤ IL ≤ 3A, 8V ≤ Vin ≤ 40V,
Feedback Voltage (Note 1)
0.96|Vo|
--
1.23
75
1.04|Vo|
--
V
Vout=5V (Figure 2)
Efficiency
Vin=12V, Vout=5V, IL=3A
%
All Output Voltage Version (Vin= 12V, IL = 500mA)
Oscillator Frequency (Note 2)
kHz
mA
uA
V
127
--
150
5
173
10
200
1.5
100
--
Quiescent Current (Note 3)
Standby Current
ENABLE =5V
--
70
1.2
50
98
4.5
0.3
7.5
--
Saturation Voltage (Note 4)
Feedback Bias Current
Duty Cycle (Note 5)
ILOAD=3A
--
nA
%
VOUT=5V (Adj. Version only)
Operating (ON)
--
93
--
A
Current Limit (Note 2)(Note 4)
--
VOUT=0V
--
2
mA
V
Output Leakage Current (Note 3)
ENABLE Threshold Voltage
ENABLE Input Current
VOUT=-1V
--
30
--
VIH (VOUT=0V)
2.0
--
VIL(VOUT=Normal Output Voltage)
IIH (ENABLE =5V)
IIH (ENABLE =0V)
--
0.6
30
10
--
12
0
uA
--
Note 1: External components such as the catch diode, inductor, input and output capacitors can affect switching regulator
system performance. Refer to Application information for details.
Note 2: The oscillator frequency reduces when the second stage current limit is activated. The amount of reduction is
determined by the severity of current over load.
Note 3: For these parameters, FB is removed from VOUT and connected to +12V to force the output transistor OFF.
Note 4: VOUT pin sourcing current. No diode, inductor or capacitor connected to VOUT.
Note 5: FB is removed from VOUT and connected to 0V.
TS2596
3-6
2003/12 rev. D
Typical Application Circuit
Figure 1 Fixed Voltage Version
Figure 2: Adjustable Voltage Version
Figure 3: LC filter for Low Output Ripple
TS2596
4-6
2003/12 rev. D
Application Data
Quick Design Component Selection Table for Fixed Output
Input / Output Condition Inductor Output Capacitor
Output Load current Max. Input voltage Inductance Current Nichicon PL series Sprague 595D series
(V)
(A)
(V)
8
(uH)
22
33
47
22
68
68
22
22
33
22
33
47
(A)
3.5
3.5
3.5
3.1
3.1
3.1
3.5
3.5
3.5
3.1
3.1
3.1
uF
V
uF
V
560
330
270
470
180
180
470
560
680
470
330
330
25
35
35
25
35
35
25
35
35
25
35
35
330
330
330
330
270
270
390
390
390
390
390
330
10
10
10
10
10
10
6.3
6.3
6.3
6.3
6.3
10
3
15
25
9
5
2
3
2
15
25
5
12
25
6
3.3
12
25
Quick Design Component Selection Table for Adjustable Output
Input / Output Condition
Output Capacitor
Feedforword
Capacitor
Output (V)
Nichicon PL series
Sprague 595D series
uF
V
uF
V
Value
33
Unit
nF
nF
nF
nF
nF
pF
pF
2
4
820
470
470
330
330
220
150
35
35
25
25
25
35
35
330
330
330
330
270
270
390
10
10
10
10
10
10
6.3
10
6
3.3
1.5
1
9
12
15
24
680
560
Schottky Diode Selection Table
Reverse Voltage Forward Rectified Current (4~6A)
(V)
20
30
40
Surface Mount
--
Through Hole
SR502
SK53C
SK54C
SR503
SR504
(Taiwan Semiconductor Part Number)
TS2596
5-6
2003/12 rev. D
TO-220-5L Mechanical Drawing
G
TO-220 DIMENSION
MILLIMETERS
H
B
A
INCHES
MIN
DIM
MIN
MAX
10.50
4.440
2.940
1.020
1.830
14.13
5.225
1.370
29.44
2.925
0.477
8.800
6.510
15.31
MAX
0.413
0.175
0.116
0.040
0.072
0.556
0.206
0.054
1.159
0.115
0.019
0.346
0.256
0.603
M
L
A
B
C
D
E
F
G
H
I
10.00
3.240
2.440
0.260
1.570
13.31
4.475
1.170
27.60
2.175
0.297
8.280
6.010
14.29
0.394
0.128
0.096
0.010
0.062
0.524
0.176
0.046
1.087
0.086
0.012
0.326
0.237
0.563
N
I
J
F
K
L
M
N
K
J
D
E
TO-263-5L Mechanical Drawing
TO-263 DIMENSION
MILLIMETERS
A
E
INCHES
DIM
F
MIN
10.220
14.600
0.750
1.573
4.560
1.240
2.280
0.280
8.240
1.540
MAX
10.260
15.870
0.770
1.827
4.570
1.270
2.790
0.320
8.280
1.800
MIN
MAX
0.404
0.625
0.030
0.072
0.180
0.050
0.110
0.013
0.326
0.071
A
B
C
D
E
F
G
H
I
0.402
0.575
0.030
0.062
0.179
0.049
0.090
0.011
0.324
0.060
J
B
I
C
G
J
D
H
TS2596
6-6
2003/12 rev. D
相关型号:
TS2596CM53.3
3A Step Down Switching Voltage RegulatorWarning: Undefined variable $rtag in /www/wwwroot/website_ic37/www.icpdf.com/pdf/pdf/index.php on line 217
-
TSC
TS2596CM533
3A Step Down Switching Voltage RegulatorWarning: Undefined variable $rtag in /www/wwwroot/website_ic37/www.icpdf.com/pdf/pdf/index.php on line 217
-
TSC
TS2596CM533RN
3A / 150KHz Buck Dc-Dc ConverterWarning: Undefined variable $rtag in /www/wwwroot/website_ic37/www.icpdf.com/pdf/pdf/index.php on line 217
-
TSC
TS2596CM55
3A Step Down Switching Voltage RegulatorWarning: Undefined variable $rtag in /www/wwwroot/website_ic37/www.icpdf.com/pdf/pdf/index.php on line 217
-
TSC
TS2596CM55.0
3A Step Down Switching Voltage RegulatorWarning: Undefined variable $rtag in /www/wwwroot/website_ic37/www.icpdf.com/pdf/pdf/index.php on line 217
-
TSC
TS2596CM550RN
3A / 150KHz Buck Dc-Dc ConverterWarning: Undefined variable $rtag in /www/wwwroot/website_ic37/www.icpdf.com/pdf/pdf/index.php on line 217
-
TSC
TS2596CM5RN
3A / 150KHz Buck Dc-Dc ConverterWarning: Undefined variable $rtag in /www/wwwroot/website_ic37/www.icpdf.com/pdf/pdf/index.php on line 217
-
TSC
TS2596CZ5
3A Step Down Switching Voltage RegulatorWarning: Undefined variable $rtag in /www/wwwroot/website_ic37/www.icpdf.com/pdf/pdf/index.php on line 217
-
TSC
TS2596CZ505
3A Step Down Switching Voltage RegulatorWarning: Undefined variable $rtag in /www/wwwroot/website_ic37/www.icpdf.com/pdf/pdf/index.php on line 217
-
TSC
TS2596CZ53.3
3A Step Down Switching Voltage RegulatorWarning: Undefined variable $rtag in /www/wwwroot/website_ic37/www.icpdf.com/pdf/pdf/index.php on line 217
-
TSC
TS2596CZ533
3A Step Down Switching Voltage RegulatorWarning: Undefined variable $rtag in /www/wwwroot/website_ic37/www.icpdf.com/pdf/pdf/index.php on line 217
-
TSC
TS2596CZ533C0
3A / 150KHz Buck Dc-Dc ConverterWarning: Undefined variable $rtag in /www/wwwroot/website_ic37/www.icpdf.com/pdf/pdf/index.php on line 217
-
TSC
©2020 ICPDF网 联系我们和版权申明