V7BC-10A1AL [BEL]
DC-DC Regulated Power Supply Module, 1 Output, 50W, Hybrid, SIP-11;![V7BC-10A1AL](http://pdffile.icpdf.com/pdf2/p00278/img/icpdf/VRBC-10A1A0G_1659940_icpdf.jpg)
型号: | V7BC-10A1AL |
厂家: | ![]() |
描述: | DC-DC Regulated Power Supply Module, 1 Output, 50W, Hybrid, SIP-11 |
文件: | 总8页 (文件大小:234K) |
中文: | 中文翻译 | 下载: | 下载PDF数据表文档文件 |
NON-ISOLATED DC/DC CONVERTERS
8.3 Vdc - 14 Vdc Input 0.75 Vdc - 5.0 Vdc/10 A Output
VRBC-10A1Ax
RoHS Compliant
Rev.A
•
•
•
•
•
•
Non-Isolated
High Efficiency
Fixed Frequency
Low Cost
•
•
•
•
Under Voltage Lockout (UVLO)
OCP/SCP
Remote Sense
Wide Trim
Industrial Temperature Range
Over Temperature Shutdown
Wide Input
•
Remote On/Off
•
•
Remote On/Off Logic
Output Voltage Prebias
•
Description
The Bel VRBC-10A1Ax modules are series of the non-isolated dc/dc converters. The modules use a SIP package.
These converters are available in a range of output voltages from 0.75 Vdc to 5.0 Vdc over a wide range of input
voltage (Vin = 8.3 Vdc - 14 Vdc).The efficiency is typically 95%@5.0 Vout at full load.
Part Selection
Output Voltage
Input Voltage
Max. Output Max. Output
Typical
Efficiency
Model Number
Active Low
Model Number
Active High
Current
Power
0.75 V - 5.0 V
8.3 V - 14 V
10 A
50.0 W
95%
VRBC-10A1AL
VRBC-10A1A0
Notes: 1. Add “G” suffix at the end of the model number to indicate “Tray Packaging”.
2. All part numbers above indicate RoHS 6. Change the second letter "R" to "7" for RoHS 5 part numbers.
Absolute Maximum Ratings
Parameter
Min
Typ
Max
Notes
Input Voltage (continuous)
-0.3 V
-
15 V
Output Enable Terminal Voltage
Ambient Temperature
-0.3 V
-40 °C
-55 °C
-
-
-
15 V
85 °C
125 °C
Storage Temperature
Note: All specifications are typical at 25 °C unless otherwise stated.
Bel Fuse Inc. 206 Van Vorst Street, Jersey City, NJ 07302 • Tel 201-432-0463 • Fax 201-432-9542 • www.belfuse.com
NON-ISOLATED DC/DC CONVERTERS
8.3 Vdc - 14 Vdc Input
0.75 Vdc - 5.0 Vdc/10 A Output
Input Specifications
Parameter
Min
Typ
Max
Notes
Operating Input Voltage
Vo≤ 3.63 V
Vo > 3.63 V
8.3 V
8.3 V
12 V
12 V
14 V
13.2 V
An input line fuse must always be
used.
Input Current (full load)
-
-
6.5 A
Input Current (no load)
-
-
80 mA
2 mA
-
-
Remote Off Input Current
Tested with one 1000 uF/25 V
Aluminum capacitor with ESR=0.03
ohm max and 4 × 47 uF/16 V
Tantalum capacitors with ESR=0.013
ohm max at 100 kHz, & simulated
source impedance of 1000 nH, 5 Hz
to 20 MHz.
Input Reflected Ripple Current (pk-pk)
-
-
100 mA
-
Input Reflected Ripple Current (rms)
30 mA
-
I2t Inrush Current Transient
Turn-on Voltage Threshold
Turn-off Voltage Threshold
-
-
-
0.2 A2s
7.9 V
0.4 A2s
-
-
7.8 V
Note: All specifications are typical at 25 °C unless otherwise stated.
Output Specifications
Parameter
Min
Typ
Max
Notes
Output Voltage Set Point
-2% Vo,set
-
2% Vo,set
Vin=12 V, full load
Load Regulation
Line Regulation
-
-
0.3% Vo,set
0.2% Vo,set
-
-
Regulation Over Temperature
(-40 °C to +85 °C)
-
0.4% Vo,set
-
Tref=Tamin to Tamax
Output Current
0 A
-
10 A
-
3 A2s
Current Limit Threshold
Short Circuit Surge Transient
Ripple and Noise (pk-pk)
-
-
-
200% Io
1 A2s
0-20 MHz BW, with 10 uF
tantalum capacitor & 1 uF
ceramic capacitor
40 mV
100 mV
Ripple and Noise (rms)
Turn on Time
-
20 mV
40 mV
20 mS
-
-
8 mS
Overshoot at Turn on
Output Capacitance
Transient Response
50% ~ 100% Max Load
Settling Time
-
-
1% Vo,set
5000 uF
0 uF
-
-
-
-
100 mV
50 uS
-
di/dt=2.5 A/uS; Vin=12 V;
and with 470 uF Tantalum
capacitors at the output
-
-
-
VO = 0.75 V -5 V
100% ~ 50% Max Load
Settling Time
100 mV
50 uS
Note: All specifications are typical at nominal input, full load at 25 °C unless otherwise stated.
Bel Fuse Inc. 206 Van Vorst Street, Jersey City, NJ 07302 • Tel 201-432-0463 • Fax 201-432-9542 • www.belfuse.com
NON-ISOLATED DC/DC CONVERTERS
8.3 Vdc - 14 Vdc Input
0.75 Vdc - 5.0 Vdc/10 A Output
General Specifications
Parameter
Min
Typ
Max
Notes
Efficiency
Vo=5.0 V
-
-
-
-
-
-
-
95%
93%
92%
90%
89%
87.5%
81%
-
-
-
-
-
-
-
Vo=3.3 V
Vo=2.5 V
Vo=1.8 V
Vo=1.5 V
Vo=1.2 V
Vo=0.75 V
Measured at Vin=12 V, full load
Switching Frequency
265 kHz
300 kHz
335 kHz
-
Over Temperature Shutdown1
Output Voltage Trim Range
Remote Sense Compensation
-
130 °C
0.7525 V
-
-
-
5.0 V
0.5 V
Calculated Per Bell Core SR-332 (IO = 80%
Load; Vo=3.3 V; Vin=12 V; Ta = 25°C)
MTBF
5,114,191 hours
Dimensions
Inches (L × W × H)
Millimeters (L × W × H)
2.0 x 0.5 x 0.32
50.8 x 12.7 x 8.13
7.1 g
Weight
-
-
Notes: All specifications are typical at 25 °C unless otherwise stated.
1. The Tref temperature measurement location:
Control Specifications
Parameter
Min
Typ
Max
Notes
Remote On/Off
Signal Low (Unit Off)
Signal High (Unit On)
Signal Low (Unit On)
Signal High (Unit Off)
-0.2 V
-
-
-
-
-
0.3 V
Vin, max
0.3 V
VRBC-10A1A0; Remote On/Off pin open, Unit
on.
-0.2 V
2.5 V
VRBC-10A1AL; Remote On/Off pin open, Unit
on.
Vin, max
Bel Fuse Inc. 206 Van Vorst Street, Jersey City, NJ 07302 • Tel 201-432-0463 • Fax 201-432-9542 • www.belfuse.com
NON-ISOLATED DC/DC CONVERTERS
8.3 Vdc - 14 Vdc Input
0.75 Vdc - 5.0 Vdc/10 A Output
Output Trim Equations
Equation for calculating the trim resistor (in Ω) given the desired adjusted voltage (Vo) is shown below. The Trim
Up resistor should be connected between the Trim pin and Ground.
Vout
Sense
10500
⎡
⎤
Module
R trim =
− 1000
⎢
⎥
trim
Vo − 0 .7525
⎣
⎦
Rtrim
GND
Equation for calculating the trim voltage (in V) given the desired adjusted voltage (Vadj) is shown below. The
Trim Up voltage should be connected between the Trim pin and Ground.
Vout
Sense
Vtrim =
{
0.7−0.0667×
Vo−0.7525)}
Module
trim
Vtrim
GND
Thermal Derating Curve
Vin=12.0 V, Vo = 3.3 V
Bel Fuse Inc. 206 Van Vorst Street, Jersey City, NJ 07302 • Tel 201-432-0463 • Fax 201-432-9542 • www.belfuse.com
NON-ISOLATED DC/DC CONVERTERS
8.3 Vdc - 14 Vdc Input
0.75 Vdc - 5.0 Vdc/10 A Output
Efficiency Data
Module 5.0V
100.0%
90.0%
80.0%
70.0%
60.0%
8.3 V
12.0 V
13.2 V
1 A
2.5 A
5 A
7.5 A
10 A
Output current
Module 3.3V
100.0%
90.0%
80.0%
70.0%
60.0%
8.3 V
12.0 V
14.0 V
1 A
2.5 A
5 A
7.5 A
10 A
Output current
Module 0.75V
90.0%
80.0%
70.0%
60.0%
50.0%
8.3 V
12.0 V
14.0 V
1 A
2.5 A
5 A
7.5 A
10 A
Output current
Bel Fuse Inc. 206 Van Vorst Street, Jersey City, NJ 07302 • Tel 201-432-0463 • Fax 201-432-9542 • www.belfuse.com
NON-ISOLATED DC/DC CONVERTERS
8.3 Vdc - 14 Vdc Input
0.75 Vdc - 5.0 Vdc/10 A Output
Ripple and Noise Waveforms
Ripple and noise at full load, 0.75 V output
Ripple and noise at full load, 3.3 V output
Ripple and noise at full load, 5.0 V output
Note: Ripple and Noise at external load with 10 uF tantalum capacitor and 1 uF ceramic on output,
Ta=25 deg C.
Bel Fuse Inc. 206 Van Vorst Street, Jersey City, NJ 07302 • Tel 201-432-0463 • Fax 201-432-9542 • www.belfuse.com
NON-ISOLATED DC/DC CONVERTERS
8.3 Vdc - 14 Vdc Input
0.75 Vdc - 5.0 Vdc/10 A Output
Transient Response Waveforms
50% to 100% load transient at 0.75 Vdc output
50% to 100% load transient at 3.3 Vdc output
50% to 100% load transient at 5.0 Vdc output
100% to 50% load transient at 0.75 Vdc output
100% to 50% load transient at 3.3 Vdc output
100% to 50% load transient at 5.0 Vdc output
Note: Transient response at Vin=12 V, di/dt=2.5 A/uS, external load with 470 uF tantalum capacitor at the
output, and Ta=25 deg C.
Bel Fuse Inc. 206 Van Vorst Street, Jersey City, NJ 07302 • Tel 201-432-0463 • Fax 201-432-9542 • www.belfuse.com
NON-ISOLATED DC/DC CONVERTERS
8.3 Vdc - 14 Vdc Input
0.75 Vdc - 5.0 Vdc/10 A Output
Mechanical Outline
Pin Connections
Pin
Function
1
Vo
Vo
2
3
Vo, sense
Vo
4
5
GND
GND
Vin
6
7
8
Vin
9
N/A
10
11
Trim
On/Off
RoHS Compliance
Complies with the European Directive 2002/95/EC, calling for the elimination of lead and
other hazardous substances from electronic products.
©2007 Bel Fuse Inc. Specifications subject to change without notice. 011707
CORPORATE
FAR EAST
EUROPE
Bel Fuse Inc.
Bel Fuse Ltd.
Bel Fuse Europe Ltd.
206 Van Vorst Street
Jersey City, NJ 07302
Tel 201-432-0463
Fax 201-432-9542
www.belfuse.com
8F/ 8 Luk Hop Street
San Po Kong
Kowloon, Hong Kong
Tel 852-2328-5515
Fax 852-2352-3706
www.belfuse.com
Preston Technology Management Centre
Marsh Lane, Suite G7, Preston
Lancashire, PR1 8UD, U.K.
Tel 44-1772-556601
Fax 44-1772-888366
www.belfuse.com
相关型号:
©2020 ICPDF网 联系我们和版权申明