GLS87DP128G3 [GREENLIANT]

Industrial / Commercial Temp SATA M.2 ArmourDrive;


型号：	GLS87DP128G3
厂家：	Greenliant
描述：	Industrial / Commercial Temp SATA M.2 ArmourDrive
文件：	总9页 (文件大小：326K)
中文：	中文翻译
下载：	下载PDF数据表文档文件

GLS87DPxxxx3 / GLS87BPxxxx3 PX Series

Industrial / Commercial Temp SATA M.2 ArmourDrive™

Factsheet 05.000

April 2020

Features

• Industry Standard SATA Host Interface

• Reliability

Mean Time Between Failures (MTBF):

2 million hours

• Integrated Current Detector

–

SATA 1.5Gb/s, 3Gb/s and 6Gb/s

SATA Revision 3.2

ATA/ATAPI-8 compliant

Supports 48-bit address feature set

Native Command Queuing (NCQ)

up to 32 commands

–

Protects from inrush current and generates

reset during power-up and power-down to

prevent inadvertent writes

• Performance

• 20-Byte Serial Number

–

Sequential data read: Up to 550 MB/s

Sequential data write: Up to 500 MB/s

(measured using 128 KB transfer size)

–

Factory pre-programmed unique ID

• Built-in ECC

–

Uses advanced LDPC bit error detection and

correction optimized for 3D NAND

• NAND Configuration

• Power Management

–

3.3V power supply

Host initialized power management (HIPM)

Device initialized power management (DIPM)

–

3 bits per cell (3D TLC NAND)

• Endurance

• Power Consumption

–

Program/Erase (P/E) cycles: 3K

–

Active mode:

• Operating Temperature Range

1TB: < 1800mW

–

Industrial: -40°C to 85°C

Commercial: 0°C to 70°C

512GB: < 1520mW

256GB: < 1450mW

128GB: < 1350mW

64GB: < 1250mW

(SSD case temperature reported by SMART)

• M.2 2242 and 2280 Form Factors

–

32GB-256GB: 22mm x 42mm x 3.10mm /

22mm x 80mm x 3.10mm

32GB: < 1100mW

–

Idle mode: < 325mW

Slumber mode: < 15mW

DevSleep mode (optional): < 5mW

–

512GB: 22mm x 42mm x 3.50mm /

22mm x 80mm x 3.50mm

1TB: 22mm x 80mm x 3.50mm

Double-sided (DS), B+M key

–

• Supports TRIM and SMART Commands

• Data Protection

• All Devices are RoHS Compliant

–

Secure erase / Data sanitization

Product Description

The GLS87DP032G3 / 064G3 / 128G3 / 256G3 /

512G3 (2242 form factor) and GLS87BP032G3 /

064G3 / 128G3 / 256G3 / 512G3 / 001T3 (2280 form

factor) Industrial and Commercial Temperature SATA

M.2 ArmourDrive™ PX Series modules (referred to as

“M.2 ArmourDrive” in this datasheet) are high-

performance, high-reliability solid state drives. They

combine 32, 64, 128, 256 or 512 GBytes, or 1 TByte

of NAND flash memory with an advanced Serial ATA

(SATA) controller on a printed circuit board (PCB).

The SATA SSD controller with built-in advanced

NAND management firmware communicates with the

host through the standard SATA protocol. It does not

require any additional or proprietary software such as

the Flash File System (FFS) and Memory Technology

Driver (MTD). The firmware effectively optimizes the

use of NAND flash memory’s program/erase (P/E)

cycles and minimizes write amplification.

M.2 ArmourDrive’s advanced NAND management

technology improves endurance, enhances data

security and helps prevent data corruption during

unexpected power failure events. This innovative

technology combines robust NAND controller

hardware error correction capabilities with advanced

wear-leveling algorithms and bad block management

to improve data reliability and significantly extend the

life of the product.

M.2 ArmourDrive is ideal for applications that require

removable form factor and more reliable data storage.

SATA M.2 solid state storage technology is widely

used in industrial computers, test and measurement

instrumentation, multi-functional printers, medical

equipment, security and surveillance systems,

network servers and digital signage. These removable

solid state drives (SSDs) surpass traditional hard disk

drives (HDDs) in their small size, security, reliability,

ruggedness and low power consumption.

These specifications are subject to change without notice.

04/29/2020

S71461-01

GLS FS0019 Rev. 00

GLS87DPxxxx3 / GLS87BPxxxx3 PX Series

Industrial / Commercial Temp SATA M.2 ArmourDrive™

Factsheet 05.000

April 2020

1.0

GENERAL DESCRIPTION

Each M.2 ArmourDrive module integrates a SATA SSD controller with NAND flash multi-chip packages. Refer to

Figure 2-1 for the M.2 ArmourDrive block diagram.

1.1.5 Power Interrupt Data Protection

1.1

Optimized M.2 ArmourDrive

Power Interrupt Data Protection is a mechanism to

help prevent data corruption during unexpected power

failure events. Enhanced data integrity is supported by

the controller’s advanced firmware during abnormal

power loss. The controller proactively optimizes the

amount and stay time of the “in-flight” data residing in

the cache. To ensure there is no data loss risk caused

by power cycling, the controller sends an

acknowledgement to the host only when the incoming

data is fully committed to the NAND flash.

The heart of M.2 ArmourDrive is the SATA SSD

controller, which translates standard SATA signals

into flash media data and control signals. The

following components contribute to M.2 ArmourDrive’s

operation.

1.1.1 Microcontroller Unit (MCU)

The MCU translates SATA commands into data and

control signals required for flash media operation.

1.1.2 Internal Direct Memory Access (DMA)

1.1.6 Error Correction Code (ECC)

M.2 ArmourDrive uses internal DMA allowing instant

data transfer from/to buffer to/from flash media. This

implementation eliminates microcontroller overhead

associated with the traditional, firmware-based

approach, thereby increasing the data transfer rate.

The ECC technology uses advanced Low Density

Parity Check (LDPC) algorithms to detect and correct

errors, ensuring data integrity and extending the SSD

lifespan.

1.1.7 Multi-tasking Interface

1.1.3 Power Management Unit (PMU)

The multi-tasking interface enables concurrent Read,

Program and Erase operations to multiple NAND flash

media.

The PMU controls the power consumption of M.2

ArmourDrive. The PMU dramatically reduces the

power consumption of M.2 ArmourDrive by putting the

part of the circuitry that is not in operation into sleep

mode.

1.2

Advanced NAND Management

The Flash File System handles inadvertent power

interrupts and has auto-recovery capability to ensure

M.2 ArmourDrive firmware integrity. For regular power

M.2 ArmourDrive’s controller uses advanced wear-

leveling algorithms to substantially increase the

longevity of NAND flash media. Wear caused by

data writes is evenly distributed in all or select

blocks in the device that prevents “hot spots” in

locations that are programmed and erased

extensively. This effective wear-leveling technique

results in optimized device endurance, enhanced

data retention and higher reliability required by

long-life applications.

management,

the

host

must

send

IDLE_IMMEDIATE command and wait for command

ready before powering down M.2 ArmourDrive.

1.1.4 Embedded Flash File System

The embedded flash file system is an integral part of

M.2 ArmourDrive. It contains MCU firmware that

performs the following tasks:

1. Translates host side signals into flash media

writes and reads

2. Provides flash media wear leveling to spread the

flash writes across all memory address space to

increase the longevity of flash media

3. Keeps track of data file structures

These specifications are subject to change without notice.

04/29/2020

S71461-01

GLS FS0019 Rev. 00

GLS87DPxxxx3 / GLS87BPxxxx3 PX Series

Industrial / Commercial Temp SATA M.2 ArmourDrive™

Factsheet 05.000

April 2020

2.0

FUNCTIONAL BLOCKS

Figure 2-1: M.2 ArmourDrive Block Diagram

These specifications are subject to change without notice.

04/29/2020

S71461-01

GLS FS0019 Rev. 00

GLS87DPxxxx3 / GLS87BPxxxx3 PX Series

Industrial / Commercial Temp SATA M.2 ArmourDrive™

Factsheet 05.000

April 2020

APPENDIX

3.0

3.1

Product Ordering Information

GLS 87 BP

XX XX

xxx x3 - I - BZ2xx

XXX XX - X - XXXXX

Ordering Code

BZ2xx = SATA M.2 ArmourDrive Revision

Operating Temperature

I = Industrial: -40°C to +85°C

C = Commercial: 0°C to +70°C

NAND Configuration

3 = 3 bits per cell

GByte or TByte Designator

G = GByte

T = TByte

Capacity

032 = 32 GByte

064 = 64 GByte

128 = 128 GByte

256 = 256 GByte

512 = 512 GByte

001 = 1 TByte

Product Generation

P = Generation

Form Factor

B = M.2 2280 (DS)

D = M.2 2242 (DS)

Product Family

87 = SATA M.2 ArmourDrive

These specifications are subject to change without notice.

04/29/2020

S71461-01

GLS FS0019 Rev. 00

GLS87DPxxxx3 / GLS87BPxxxx3 PX Series

Industrial / Commercial Temp SATA M.2 ArmourDrive™

Factsheet 05.000

April 2020

Valid Combinations

Valid product combinations are those that are in the mass production or will be in the mass production. Consult

your Greenliant sales representative to confirm availability of the valid combinations and to determine availability

of new product combinations.

Table 3-1: M.2 2242 ArmourDrive Product Valid Ordering Numbers

Capacity

32GB

64GB

Operating Temperature

Industrial (-40°C to 85°C)

Commercial (0°C to +70°C)

Industrial (-40°C to 85°C)

Commercial (0°C to +70°C)

Industrial (-40°C to 85°C)

Commercial (0°C to +70°C)

Industrial (-40°C to 85°C)

Commercial (0°C to +70°C)

Industrial (-40°C to 85°C)

Commercial (0°C to +70°C)

Part Number

Form Factor

GLS87DP032G3-I-BZ200

GLS87DP032G3-I-BZ202

GLS87DP032G3-C-BZ200

GLS87DP064G3-I-BZ200

GLS87DP064G3-I-BZ202

GLS87DP064G3-C-BZ200

GLS87DP128G3-I-BZ200

GLS87DP128G3-I-BZ202

GLS87DP128G3-C-BZ200

GLS87DP256G3-I-BZ200

GLS87DP256G3-I-BZ202

GLS87DP256G3-C-BZ200

GLS87DP512G3-I-BZ200

GLS87DP512G3-I-BZ202

GLS87DP512G3-C-BZ200

2242 (DS), B+M key

64GB

128GB

256GB

512GB

These specifications are subject to change without notice.

04/29/2020

S71461-01

GLS FS0019 Rev. 00

GLS87DPxxxx3 / GLS87BPxxxx3 PX Series

Industrial / Commercial Temp SATA M.2 ArmourDrive™

Factsheet 05.000

April 2020

Table 3-2: M.2 2280 ArmourDrive Product Valid Ordering Numbers

Capacity

32GB

64GB

128GB

256GB

512GB

1TB

Operating Temperature

Industrial (-40°C to 85°C)

Commercial (0°C to +70°C)

Industrial (-40°C to 85°C)

Commercial (0°C to +70°C)

Industrial (-40°C to 85°C)

Commercial (0°C to +70°C)

Industrial (-40°C to 85°C)

Commercial (0°C to +70°C)

Industrial (-40°C to 85°C)

Commercial (0°C to +70°C)

Industrial (-40°C to 85°C)

Commercial (0°C to +70°C)

Part Number

Form Factor

GLS87BP032G3-I-BZ200

GLS87BP032G3-I-BZ202

GLS87BP032G3-C-BZ200

GLS87BP032G3-C-BZ201

GLS87BP064G3-I-BZ200

GLS87BP064G3-I-BZ202

GLS87BP064G3-C-BZ200

GLS87BP064G3-C-BZ201

GLS87BP128G3-I-BZ200

GLS87BP128G3-I-BZ202

GLS87BP128G3-C-BZ200

GLS87BP128G3-C-BZ201

GLS87BP128G3-C-BZ203

GLS87BP256G3-I-BZ200

GLS87BP256G3-I-BZ202

GLS87BP256G3-C-BZ200

GLS87BP256G3-C-BZ201

GLS87BP256G3-C-BZ203

GLS87BP512G3-I-BZ200

GLS87BP512G3-I-BZ202

GLS87BP512G3-C-BZ200

GLS87BP512G3-C-BZ201

GLS87BP512G3-C-BZ203

GLS87BP001T3-I-BZ200

GLS87BP001T3-I-BZ202

GLS87BP001T3-C-BZ200

GLS87BP001T3-C-BZ201

2280 (DS), B+M key

1TB

These specifications are subject to change without notice.

04/29/2020

S71461-01

GLS FS0019 Rev. 00

GLS87DPxxxx3 / GLS87BPxxxx3 PX Series

Industrial / Commercial Temp SATA M.2 ArmourDrive™

Factsheet 05.000

April 2020

3.2

Board Diagrams

BOTTOM VIEW

TOP VIEW

SIDE VIEW (512GB)

SIDE VIEW (32GB-256GB)

Note:

All dimensions are in millimeters, unless otherwise specified.

Figure 3-1: M.2 2242 ArmourDrive Dimensions

These specifications are subject to change without notice.

04/29/2020

S71461-01

GLS FS0019 Rev. 00

GLS87DPxxxx3 / GLS87BPxxxx3 PX Series

Industrial / Commercial Temp SATA M.2 ArmourDrive™

Factsheet 05.000

April 2020

BOTTOM VIEW

TOP VIEW

SIDE VIEW (32GB-256GB)

SIDE VIEW (512GB-1TB)

Note:

All dimensions are in millimeters, unless otherwise specified.

Figure 3-2: M.2 2280 ArmourDrive Dimensions

These specifications are subject to change without notice.

04/29/2020

S71461-01

GLS FS0019 Rev. 00

GLS87DPxxxx3 / GLS87BPxxxx3 PX Series

Industrial / Commercial Temp SATA M.2 ArmourDrive™

Factsheet 05.000

April 2020

Revision History

Revision

01.000

Description

Date

Initial release as Factsheet

November 08, 2018

January 16, 2019

02.000

Added SATA M.2 2242 product information

Updated Product Description (page 1) and Power Interrupt Data

Protection (section 1.1.5)

Added Commercial Temperature part numbers;

Updated Features descriptions on page 1; Updated Table 3-1 and 3-2

02.001

03.000

January 30, 2019

June 13, 2019

03.001

04.000

Updated Features descriptions on page 1

July 26, 2019

Added BZ201 part numbers; Updated Power Consumption on page 1

November 27, 2019

Updated Features descriptions on page 1; Added BZ202 and BZ203 part

numbers

05.000

April 29, 2020

Greenliant and the Greenliant logo are registered trademarks, and ArmourDrive is a trademark of Greenliant. All

other trademarks and registered trademarks are the property of their respective owners.

Specifications are subject to change without notice. Memory sizes denote raw storage capacity; actual usable

capacity may be less.

Greenliant makes no warranty for the use of its products other than those expressly contained in the Greenliant

Terms and Conditions of Sale.

www.greenliant.com

These specifications are subject to change without notice.

04/29/2020

S71461-01

GLS FS0019 Rev. 00

GLS87DP128G3 [GREENLIANT]

相关型号：

SI9130DB

SI9135LG-T1

SI9135LG-T1-E3

SI9135_11

SI9136_11

SI9130CG-T1-E3

SI9130LG-T1-E3

SI9130_11

SI9137

SI9137DB

SI9137LG

SI9122E