1018209 [SICK]
MULTIPLE LIGHT BEAM SAFETY DEVICES;
| 型号： | 1018209 |
| 厂家： | 
SICK AG |
| 描述： | MULTIPLE LIGHT BEAM SAFETY DEVICES 端子和端子排 |
| 文件： | 总6页 (文件大小：1112K) |
| 中文： | 中文翻译 | 下载： | 下载PDF数据表文档文件 |
M20S-081A3A122, M20E-081A3A222
M2000 RES/EDM
MULTIPLE LIGHT BEAM SAFETY DEVICES
M20S-081A3A122, M20E-081A3A222 | M2000 RES/EDM
MULTIPLE LIGHT BEAM SAFETY DEVICES
Ordering information
A
B
C
D
E
F
System part
Sender
Type
Part no.
1018198
1018235
M20S-081A3A122
M20E-081A3A222
Receiver
1.) Concerns installation as a replacement part for previous type 2 device in machine: Regarding Machinery Directive
2006/42/EC, Article 1, Paragraph (2a) this type 2 device may only be used as a replacement part for identical PL d / SIL2
devices within the EU if the machine was put into circulation before 2015-05-10. Keep this note with your machine documen-
tation. If the machine is sold on, this note and the information it contains must be passed on to every subsequent buyer. 2.)
Concerns installation on new machines: Due to the amendment to the EN/IEC 61496-1 standard, this type 2 device may only
be installed on new machines up to PL c / SIL1 as of 2015-05-10.
Other models and accessories www.sick.com/M2000_RES_EDM
Detailed technical data
Safety-related parameters
Type
Type 2 (IEC 61496)
SIL1 (IEC 61508)
SILCL1 (EN 62061)
Safety integrity level
H
I
Category 2 (EN ISO 13849)
13 /s (EN ISO 13849) 1)
Category
Test rate (internal test)
≤ 8 min⁻¹ (EN ISO 13849) 2)
Maximum demand rate
Performance level
J
PL c (EN ISO 13849)
6.6 x 10-9 (EN ISO 13849)
PFHD (mean probability of a dangerous fail-
ure per hour)
K
L
20 years (EN ISO 13849)
TM (mission time)
At least one OSSD is in the OFF state.
Safe state in the event of a fault
1)
Internal test. The test rate may not be exceeded if an external test is performed.
2)
Between two requirements on a safety-related response of the device, at least 100 internal or external tests must be carried out.
M
N
O
P
Q
R
S
T
Functions
Functions
Delivery status
✔
✔
✔
Restart interlock
Uncoded
Beam coding
Configurable scanning range
Interfaces
System connection
Connection type Male connector M12, 8-pin
Conductor cross-section 0.25 mm²
≤ 15 m 1)
Permitted cable length
Permitted cross-section ≥ 0.25 mm²
1)
2)
Depending on load, power supply and wire cross-section. The technical specifications must be observed.
For additional information on Flexi Soft -> www.sick.com/Flexi_Soft.
2
OPTO-ELECTRONIC PROTECTIVE DEVICES | SICK
Online data sheet | 2017-06-14 08:06:28
Subject to change without notice
M20S-081A3A122, M20E-081A3A222 | M2000 RES/EDM
MULTIPLE LIGHT BEAM SAFETY DEVICES
Hard wired
Configuration method
Display elements
LEDs
7-segment display
Fieldbus, industrial network
CANopen, DeviceNet™, EtherCAT®, EtherNet/IP™, Modbus TCP, PROFIBUS DP, PROFINET 2)
Integration via Flexi Soft safety controller
1)
Depending on load, power supply and wire cross-section. The technical specifications must be observed.
For additional information on Flexi Soft -> www.sick.com/Flexi_Soft.
2)
Electrical data
III (EN 50178)
Protection class
Supply voltage VS
24 V DC (19.2 V DC ... 28.8 V DC) 1)
≤ 3.7 W (DC)
Power consumption
Safety outputs (OSSD)
Type of output 2 PNP semiconductors, short-circuit protected, cross-circuit monitored
1)
The external voltage supply must be capable of buffering brief mains voltage failures of 20 ms as specified in EN 60204-1. Suitable power supplies are available as
accessories from SICK.
Mechanical data
48 mm x 40 mm
Housing cross-section
Ambient data
IP65 (EN 60529)
Enclosure rating
0 °C ... +55 °C
Ambient operating temperature
Storage temperature
Air humidity
–25 °C ... +70 °C
15 % ... 95 %, Non-condensing
5 g, 10 Hz ... 55 Hz (IEC 60068-2-6)
10 g, 16 ms (IEC 60068-2-29)
Vibration resistance
Shock resistance
Other information
950 nm
Wave length
2017-06-14 08:06:28 | Online data sheet
Subject to change without notice
OPTO-ELECTRONIC PROTECTIVE DEVICES | SICK
3
M20S-081A3A122, M20E-081A3A222 | M2000 RES/EDM
MULTIPLE LIGHT BEAM SAFETY DEVICES
Dimensional drawing (Dimensions in mm (inch))
A
B
C
D
E
F
1.7
(0.07)
8
(0.31)
42.9
(1.69)
2
1
Ø 8.4
3 (0.33)
4
11.9
(0.47)
20
(0.79)
48
(1.89)
5
14
40
(1.57)
(0.55)
6
(0.24)
42.3
(1.67)
10.5
(0.41)
22.4
(0.88)
25.6
(1.01)
H
I
42.6
(1.68)
J
6
Number
of beams
Beam sep-
aration
Resolution
L1
L2
L3
L4
L5
L6
K
L
2
3
4
6
7
8
8
9
500 (19.69)
-
630 (24.80)
931 (36.65)
697 (27.44)
998 (39.29)
588 (23.15)
718 (28.27)
655 (25.79)
675 (26.57)
976 (38.43)
400 (15.75)
-
888 (34.96) 1,019 (40.12) 956 (37.64)
300 (11.81)
-
1,031 (40.59) 1,098 (43.23) 989 (38.94) 1,119 (44.06) 1,056 (41.57) 1,076 (42.36)
916 (36.06) 983 (38.70) 874 (34.41) 1,004 (39.53) 941 (37.05) 960 (37.80)
1,073 (42.24) 1,140 (44.88) 1,031 (40.59) 1,161 (45.71) 1,098 (43.23) 1,118 (44.02)
851 (33.50) 919 (36.18) 809 (31.85) 939 (36.97) 877 (34.53) 896 (35.28)
-
-
-
-
-
170 (6.69)
170 (6.69)
116 (4.57)
170 (6.69)
170 (6.69)
M
N
O
P
Q
R
S
T
1,231 (48.46) 1,298 (51.10) 1,189 (46.81) 1,319 (51.93) 1,256 (49.45) 1,275 (50.20)
1,388 (54.65) 1,455 (57.28) 1,346 (52.99) 1,476 (58.11) 1,413 (55.63) 1,433 (56.42)
4
OPTO-ELECTRONIC PROTECTIVE DEVICES | SICK
Online data sheet | 2017-06-14 08:06:28
Subject to change without notice
M20S-081A3A122, M20E-081A3A222 | M2000 RES/EDM
MULTIPLE LIGHT BEAM SAFETY DEVICES
Recommended accessories
Other models and accessories www.sick.com/M2000_RES_EDM
Brief description
Type
Part no.
Mounting brackets and plates
4 pieces, Mounting kit 1, mounting bracket, rigid, L-shaped, including fixing screws
BEF-3WNGBAST4
7021352
and washers
Terminal and alignment brackets
4 pieces, Mounting kit 6, side bracket, rotatable, Zinc diecast
BEF-1SHABAZN4
BEF-2SMMEAAL4
BEF-2SMMEAKU4
2019506
2044847
2019659
4 pieces, Omega bracket, rotatable, fixable with only one screw, for mounting on the
swivel mount
4 pieces, Mounting kit 2, rotatable, swivel mount, Polyamide PA6
Alignment aids
Laser alignment aid for various sensors, laser class 2 (IEC 60825). Do not look into
the beam!
AR60
1015741
4032461
4056731
Adapter AR60 for housing cross-section 48 mm x 40 mm
AR60 adapter, 48x40
Adapter AR60 for housing cross-section 48 mm x 40 mm in PU3H device column
AR60 adapter,
48x40, PU3H
2017-06-14 08:06:28 | Online data sheet
Subject to change without notice
OPTO-ELECTRONIC PROTECTIVE DEVICES | SICK
5
相关型号：
©2020 ICPDF网 联系我们和版权申明